Avalon Stoves Stove manual Seal the cover

Page 18

1 8 Installation (For Qualified Installers Only)

Installation Example: Zero-Clearance (Metal) Fireplace Hearth Stove

Vertical Cap

Storm Collar

Cover Plate (non-combustible)

Silicone	Seal the cover
	plate with silicone.

“L” Vent

“L” Vent Flex

Section

.RTV °F 500Silicone

Seal each vent section (including adapters, elbows, etc...) by injecting a liberal amount of 500° F. RTV silicone into the gap between sections.

Allow room for the hopper lid to open

57-1/2”

3”

6” Min.

NOTE: you will probably need a short horizontal section here to clear the lintel and allow the hopper lid to open.

© Travis Industries

4080725

100 - 0115 4

Image 18

Contents

Astoria Travis Industries 2IntroductionIntroduction Important Information 100 0115Table of Contents 4Safety Precautions Safety Precautions Mobile Home6Specifications Stove Placement Installation OptionsPlanning The Installation Before You BeginClearances Straight Installation Clearances Corner InstallationVenting the Pellet Stove Maximum Venting DistanceInstalling the Pellet Vent Pellet Vent TypePellet Vent Termination Mobile Home Requirements Outside Air used for combustionRestrictor Adjustment Alcove Installation RequirementsBaffle Installation Door Seal VerificationThermostat Installation Robertshaw Installation Example Direct Through-the-wall Installation Installation Example Interior Vertical Installation Installation Example Class a Chimney Retrofit Installation Example Masonry Fireplace Hearth Stove Seal the cover Installation Example Freestanding Masonry Chimney Location of Controls Safety Notice0Operation Starting the Heater for the First TimeOperation2 Loading PelletsTwo Modes of Operation 2Operation Manual ModeTo Adjust the Heat To StartAuto Mode To Adjust Room Temperature or Start the StoveAdjusting the Fan Speed 4OperationMaintenance Required Light Start-Up SequenceAuger on Light 6Operation Power OutagesUsing a Pellet/Corn Mix with This Heater Manual Auger ButtonInspect the Burn Maintenance2Daily Maintenance whenever using the stove Make Sure Pellets are Not Piling Up8Maintenance Cleaning the FirepotCheck Firepot for Clinkers Door Opening Clean the Hopper 0MaintenanceWeekly Maintenance or every 5 bags of pellets Clean the Heat Exchange TubesMaintenance3 Cleaning the Optional Gold Surfaces Door and optional GrillClean the Baffles 2Maintenance Sweep Ash Into AshpanClean the Glass Check Ashpan, Dispose if necessary4Maintenance Yearly Maintenance or every tonClean the Vertical Exhaust Duct Clean the Exhaust Blower Clean the Vent6Maintenance Door SealDoor Alignment Adjusting the Door Hinge and Latch Latch AdjustmentReplacement Parts Check for Air Leaks Around the Door, Glass, and AshpanNormal Operating Sounds Exhaust BlowerSafety Label Serial NoLimited 7 Year Warranty Years 1 & 2 Coverage Parts & Labor2Index