Avalon Stoves Stove manual Astoria

Page 1

Astoria™

Pellet Stove

• Horizontal Or Vertical Vent

• Freestanding Stove

• Mobile Home Approved

• Class A Chimney Retrofit

• Hearth Stove into Existing Masonry Chimney , Masonry Fireplace, or Z.C. Fireplace

Tested and Listed by

Omni-Test Laboratories, Inc.

Portland, Oregon

Report # 028-S-42-2

ASTM E1509-2004

- - Please read this entire manual before installation and use of this pellet fuel- burning room heater. Failure to follow these instructions could result in property damage, bodily injury, or even death.

-- Contact local building or fire officials about restrictions and installation inspection requirements in your area.

-- Save these instructions.

Installer: After installation give this manual to the home-owner and

	explain operation of this stove.
$10.00	 Copyright 2008, T.I.	Part # 100-01154
	4080725

4800 Harbour Pointe Blvd. SW Mukilteo, WA 98275

Image 1

Contents

Astoria Introduction Important Information 2IntroductionTravis Industries 100 0115Table of Contents 4Safety Precautions Mobile Home Safety Precautions6Specifications Planning The Installation Installation OptionsStove Placement Before You BeginClearances Corner Installation Clearances Straight InstallationMaximum Venting Distance Venting the Pellet StovePellet Vent Type Installing the Pellet VentPellet Vent Termination Outside Air used for combustion Mobile Home RequirementsBaffle Installation Alcove Installation RequirementsRestrictor Adjustment Door Seal VerificationRobertshaw Thermostat InstallationInstallation Example Direct Through-the-wall Installation Installation Example Interior Vertical Installation Installation Example Class a Chimney Retrofit Installation Example Masonry Fireplace Hearth Stove Seal the cover Installation Example Freestanding Masonry Chimney 0Operation Safety NoticeLocation of Controls Starting the Heater for the First TimeLoading Pellets Operation2Two Modes of Operation To Adjust the Heat Manual Mode2Operation To StartTo Adjust Room Temperature or Start the Stove Auto Mode4Operation Adjusting the Fan SpeedStart-Up Sequence Maintenance Required LightAuger on Light Using a Pellet/Corn Mix with This Heater Power Outages6Operation Manual Auger ButtonDaily Maintenance whenever using the stove Maintenance2Inspect the Burn Make Sure Pellets are Not Piling UpCleaning the Firepot 8MaintenanceCheck Firepot for Clinkers Door Opening Weekly Maintenance or every 5 bags of pellets 0MaintenanceClean the Hopper Clean the Heat Exchange TubesCleaning the Optional Gold Surfaces Door and optional Grill Maintenance3Clean the Baffles Sweep Ash Into Ashpan 2MaintenanceCheck Ashpan, Dispose if necessary Clean the GlassYearly Maintenance or every ton 4MaintenanceClean the Vertical Exhaust Duct Clean the Vent Clean the Exhaust BlowerDoor Seal 6MaintenanceDoor Alignment Latch Adjustment Adjusting the Door Hinge and LatchCheck for Air Leaks Around the Door, Glass, and Ashpan Replacement PartsExhaust Blower Normal Operating SoundsSerial No Safety LabelYears 1 & 2 Coverage Parts & Labor Limited 7 Year Warranty2Index