Monessen Hearth VFCS20DPV, VFCS30DNV, VFCS30DPV, VFCS20DNV MILLI-VOLT Control Lighting Instructions

Page 22

OPERATING INSTRUCTIONS

MILLI-VOLT

CONTROL LIGHTING INSTRUCTIONS

1.STOP! Read the safety information label.

2.Make sure the manual shutoff valve is fully open.

3.This gas log set is equipped with an ignition device (piezo) which automatically lights the pilot. If piezo ignitor does not light the pilot, refer to instructions for Match Lighting Instructions, page 23.

4.Turn gas control knob clockwise to the OFF position, turn ON/OFF switch to OFF position.

5.Wait (5) minutes to clear out any gas. Then smell for gas, including near the floor. If you smell gas, STOP! Follow the instructions under What To Do If You Smell Gas, page 21.

6.From OFF position, turn the gas control knob counterclockwise to IGN position. Push in control knob for 5 seconds. NOTE: If you are running the heater for the first time, it may be necessary to press in the control knob for 30 seconds or longer to allow air to bleed out of the gas piping.

7.With the control knob pushed in, push in and release the piezo ignitor button to light the pilot.

8.Continue pushing the control knob in for a further 10 seconds to prevent the flame detector from shutting off the gas while the probe is warming up. Release the control knob.

9.Turn gas control knob counterclockwise to the ON position.

10.After the pilot has been lit for one minute, the burners can be turned on. Turn the ON/OFF switch to ON position.

11.If the gas logs will not operate, follow the instructions “To Turn Off Gas To Heater” below and call your service technician or gas supplier.

Hi/Lo Control

Ignitor/Pilot Control

 

O

N

 

 

O

FF

 

 

On/Off Switch

(Located on Side

of Stove)

Figure 21 - Pilot

Figure 22 - Control Cover Plate for Milli-Volt

TO TURN OFF GAS TO HEATER

1.Turn ON/OFF switch to OFF position.

2.Turn control knob clockwise to OFF position to completely shut off the heater.

3.If applicable: Turn off all electric power to the heater.

22

58D6002

Page 21 Page 23
Image 22
Page 21 Page 23
Contents What to do if YOU Smell GAS Natural Gas or Propane/LPG Milli-Volt ControlRead and Save These Instructions Contents Important Safety Information Installer OwnerImportant Safety Information Door Product featuresHandle Handle HereDimensions 21 1 26 3 28 1 16 1 19 3What you will need for installation Make sure you have received all partsNatural Gas Product SpecificationsPropane / LPG Codes General Installation InformationAdequate Combustion and Ventilation AIR Counter Cast Iron Stove L1 = 151/2 Ft., L2 = 12 Ft., W = 12 Ft., H = 8 FtFront View Corner Installation Wall InstallationClearances / Height Requirements Side ViewWidth Tested Minimum Alcove Dimensions Height FromClearances / Height Requirments VF20 38½ VF30Pallet Hearth Door Removing Unit from CratePlastic Bag Ash Lip Control DoorConnecting the GAS Manual Shutoff Gas Supply Inlet ValvePropane/L.P.G. tank can cause an Checking GAS Pressure and connecting remote receiverConnecting directly to an unregulated ExplosionElectrical Wiring Milli-volt LOG Placement LOG Placement Bend in Rock Wool Tray Rock WoodMilli-volt Control Flame appearanceChecking pilot flame Thermocouple For Natural For LPOperating Instructions Flame AppearanceChecking Burner Flame Middle LogOperating Instructions Off/Pilot/On Knob OptionalMILLI-VOLT Control Lighting Instructions Operating Instructions and Cleaning and Servicing Cleaning and ServicingReplacement parts VF20 Replacement Parts listBurner assembly Description Qty Natural PropaneFailure to position the parts Burner assembly VF30Accordance with these diagrams or Failure to use only parts specifically58D0435 Union Tee 43D018158D0193 58D0061 58D0056Logs Description Qty VF30Troubleshooting Symptom Possible Cause ActionWhen con Carbon Monoxide Detector Requirements Limited Lifetime Warranty

VFCS20DNV, VFCS20DPV, VFCS30DPV, VFCS30DNV specifications

Monessen Hearth has long been synonymous with high-quality and efficient heating solutions, and their range of direct-vent gas fireplaces, including the VFCS30DNV, VFCS30DPV, VFCS20DPV, and VFCS20DNV models, exemplify this commitment. These fireplaces offer both aesthetic appeal and advanced technology, making them suitable for any home.

One of the key features of the VFCS series is its impressive heat output. The VFCS30DNV and VFCS30DPV are designed to deliver substantial warmth, making them ideal for larger spaces. With a heat output of up to 30,000 BTUs, these models ensure consistent and comfortable heating during the cold months. The VFCS20 variants, while slightly smaller, still provide a robust performance with a maximum output of 20,000 BTUs, making them perfect for cozy living rooms or smaller areas.

In terms of design, these fireplaces are incredibly versatile, featuring sleek and modern aesthetic options. The VFCS models come with a wide viewing area, framed with stylish surrounds, which allows for an expansive view of the mesmerizing flame patterns. Additionally, they offer a choice of interior finishes like traditional brick or contemporary black, letting homeowners customize their fireplace to match their interior décor.

Incorporating advanced technology, these fireplaces use a direct vent system, ensuring efficient combustion and optimal heat distribution. This system allows for the safe venting of gases outside, creating a cleaner and healthier indoor atmosphere. The fireplaces operate on natural gas or propane, providing flexibility based on the homeowner's preferences and availability.

Moreover, Monessen Hearth's VFCS models are equipped with user-friendly controls, enhancing the overall functionality. The optional remote control and wall switch make it easy to operate the fireplace, allowing users to adjust the flame height and heat output according to their comfort level without the need to leave their seat.

Energy efficiency is another hallmark of these fireplaces. With high-efficiency ratings, they provide significant savings on heating bills while delivering a cozy environment. The multi-functionality of the VFCS series also allows for the addition of decorative elements, such as glass media or logs, further enhancing the atmospheric appeal.

In summary, Monessen Hearth's VFCS30DNV, VFCS30DPV, VFCS20DPV, and VFCS20DNV models bring together aesthetics, efficiency, and advanced technology, making them an exceptional choice for anyone looking to add warmth and elegance to their home. Whether for heating a spacious area or a snug room, these direct-vent gas fireplaces meet a variety of needs with style and reliability.
Top Page Image Contents