Sonic Alert manual MS30H/MS30E Mixer Safety Chain Connection

Page 19

MS30H/MS30E MIXER — SAFETY CHAIN CONNECTION

 

CAUTION

Always Tow with

 

a Safety Chain

 

 

NEVER! tow the mixer with the safety chain removed. The safety chain is intended to prevent complete separation of the mixer from the towing vehicle in the event of a tow bar failure.

Reference Figure 5 for the installation of the safety chain.

Tow Bar to Mixer Connection

1.Insert the tow bar through the round opening at the bottom of the mixer stand.

Align the hole on the tow bar with the hole on the mixer frame, and insert 1/2-inch bolt through tow bar and frame. Secure tow bar to frame with 1/2-inch nylock nut.Tighten to 40 ft.-lbs.

2.Route the safety chain through the holes just above the tow bar, located on each side of the mixer stand.

Loop the chain together and place under the tow bar. Secure the loop with the connector link.

3.extend the safety chain along the length of the tow bar, looping it through the tow bar's connector link. Remove any excess chain slack.

4.Connect the free end of (clevis safety hook) the safety chain to the towing vehicle. Remember it is critical that the length of the chain be properly adjusted, to prevent the draw bar and the front of the mixer stand from dropping to the the ground (contact) in the event the draw bar becomes disconnected from the towing vehicle.

 

CAUTION

Drum Saftey

 

when Towing

 

 

DO NOT tow the mixer unless the mixing drum is completely empty. ALWAYS make sure the drum latch pin is fully engaged to the right (Figure 6) of the drum stop block. This will keep the drum from rotating.

Figure 5. Mixer Safety Chain and Coupler

Figure 6. Drum Latch Pin (Tow or Locked Position)

MQ STOW MS30H/MS30E MIXER — PARTS & OPERATION MANUAL — REV. #4 (08/10/06) — PAGE 19

Image 19
Contents PLASTER/MORTAR Mixer Page Heres HOW to GET Help Table of Contents Direct TOLL-FREE access to our Parts Department MS-20 Mixer Safety Message Alert Symbols Protection Surrounding environment MS-20 Mixer Safety Message Alert SymbolsMS30H/MS30E Mixer Rules for Safe Operation Transporting Maintenance SafetyEmergencies Mixer Operation and Safety Decals Machine Safety DecalsMS30H/MS30E Mixer Specifications MS30H/MS30E Mixer General Information MS30H/MS30E Mixer Basic Engine Components Electric Motor Electric MotorVoltage SwitchElectric Motor Connection MS30H/MS30E Mixer Electric Motor MS30H/MS30E Mixer Controls Mixer Trailer Vehicle Connection MS30H/MS30E Mixer -TOWING GuidelinesMS30H/MS30E Mixer Safety Chain Connection MS30H/MS30E Mixer -TRAILER Safety Guidelines MS30H/MS30E Mixer -TRAILER Safety Guidelines MS30H/MS30E Mixer Paddle Blade Adjustment Engine Oil Check Before StartingBlade Check Controls Start/Stop SwitchesFuel Check Belt CheckChoke Lever Starting gasoline onlyMS30H/MS30E Mixer Initial START-UP Stoppingthe Mixer gasoline Mixing DumpingStoppingthe Mixer electric MS30H/MS30E Mixer Maintenance MS30H/MS30E Mixer -TROUBLESHOOTING Engine MS30H/MS30E Mixer -TROUBLESHOOTING Engine MS30H/MS30E Mixer -TROUBLESHOOTING MIXER/MOTOR MS30H/MS30E Mixer -WIRING Diagram Electric Motor Page Items Found In the Items Number Column Items Found In the Remarks ColumnMS30H/MS30E Mixer Suggested Spare Parts MS30H/MS30E Mixer Nameplate and Decals TBD Decal Caution Read TBD Decal Stow MultiquipDecalwarning Decal Prop TBDMS30H/MS30E Mixer Honda Engine Assy Lock Washer 3/8 Power Mount SpringPillow Block Bearing Flat Washer 3/8MS30H/MS30E Mixer Electric Motor ASSY. Electric Pinion & Shaft Pillow BlockMotor & Control Assy Motor Mount UnitMS30H/MS30E Mixer Steeltub Assy Lift BAR DrumGrate Trunnion HUBMS30H/MS30E Mixer Paddle Shaft Assy Scraper Short Wiper LongScraper Long Wiper ShortMS30H/MS30E Mixer Axle Assy Seal Axle WasherBearing CUP Bearing ConeMS30H/MS30E Mixer Frame Assy Engine Mount Shaft Safety ChainMain Frame Unit UP to S/N SECMS30H/MS30E Mixer Engine Cover Assy Latch Assy Stop SwitchEngine House Assy RED KnobAIR Cleaner Assy COLLAR, AIR Cleaner ELEMENT, AIR CLEANER, DualCOVER, AIR Cleaner GROMMET, AIR CleanerCamshaft Assy ARM Valve Rocker SPRING, Weight ReturnCamshaft ROD PushCarburetor Assy Float SET PLATE, Lever SettingGasket SET Valve SET, FloatControl Assy SPRING, Throttle Return ARM, GovernorROD, Governor SPRING, GovernorCrankcase Cover Assy Type Balancer WEIGHT, GovernorHOLDER, Governor Weight PIN, Governor WeightCrankshaft Assy Crankshaft L- Type Weight BalancerCylinder Barrel Assy OIL Seal Switch ASSY., OIL LevelSHAFT, Governor ARM BOLT, Drain PlugCylinder Head Assy GASKET, Cylinder Head GUIDE, VALVE, OS, OptionalGUIDE, EX. VALVE, OS, Optional CLIP, Valve GuideFAN Cover Assy Shroud Switch ASSY., Engine StopCLIP, Wire Harness CLIP, TubeFlywheel Assy KEY, Special Woodruff FAN, CoolingFlywheel Comp NUT, Special 16MMMuffler Assy PIPE, EX MufflerPROTECTOR, Muffler PROTECTOR, EX. PipeFuel Tank Assy GASKET, Fuel Filler CAP Rubber Supporter 107MMJOINT, Fuel Tank Tank COMP., Fuel *NH1*, BlackIgnition Coil Assy CAP ASSY., Noise Suppressor GROMMET, WireWIRE, Stop Switch 370MM Coil ASSY., IgnitionPiston Assy PISTON, Standard BOLT, Connecting RODRing SET, PISTON, STD Ring SET, PISTON, 0.75, OptionalRecoil Starter Assy SPRING, Starter Return PULLEY, Recoil StarterRATCHET, Starter SPRING, FrictionGear Reduction Assy Shim a Optional GEAR, Primary Drive 17TCountershaft SHAFT, P.T.O. H- TypeLabel Assy LABEL, Caution Labels AssyEMBLEM, Internal MARK, CAUTION, ExternalTerms and Conditions of Sale Stow Construction Equipment Page Heres HOW to GET Help