Craftsman 917.254611 Iwith Parking Engaged Nuta, Jam Nut, Disc Brake, Square KEY Reartire only

Page 14

REPAIR AND ADJUSTMENT

IWITH PARKING

ENGAGED)

NUT"A"

BRAKE

JAM NUT

BRAKE

ARM

DISC BRAKE

RGUREIO

HUB CAP WASHERS

KLIP RING

SQUARE KEY (REARTIRE ONLY)

FIGURE 11

FIGURE 12

@A GRADE 5 HEAT TREATED

BOLT CAN BEIDENTIFIED BY THREE LINES ON THE BOLT

HEAD ASSHOWN ATLEFT.

1. Brake Adjustment

This tractor is equipped with an adjustable brake system mountedon the nghtside of the transaxle (Fig. 10).

IIIIII UUlIIIIIIIII

SIX FEET (1.8 METERS) STOPPING

IFDISTANCETRACTORINREQUIRESHIGHEST GEAR,MORE THANTHEN

BRAKE MUST BE ADJUSTED.

aDepress clutctVbrake pedal and engage parking brake.

b_ Measure distance between brake operating arm and nut "A" on brake rod,,

c.tf distance is other than 1-1/2" (3.81 cm), loosen

jam nut (Fig, 10) and turn nut until distance be- comes 1-1/2" (3,81 cm)_ Relighten jam nut against nut "A".

Road test tractor for proper stopping distance as stated above, Readjust ff necessary,, If stopping distance is still

greater than 6 feet (1.8 meters) in highest gear, further maintenance is necessary Contact your local Sears Serv-

ice Center,

2.Tire Care

a, Maintain tire pressure in front at 14 PSI (lKg/cm 2) and rear tires at 10 PSI (0,7 Kg/cm2)

bKeep tires free of gasoline, oil, or insect control chemicals which can harm rubber,.

cAvoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.

d, Removing wheel for tire repair (Fig,,11). 1, Block up axle securely,

2.Remove hub cap, klip ring and washer to allow wheel removal (rear wheel contains a square key - Do Not Lose).

3.Repair tire and reassemble. Align slots in rear wheel hub and axle. Insert square key. Re- place washers and snap klip ring securely in axle groove. Replace hub cap,,

NOTE: USE GREASE FITTINGS TO LUBRICATE FRONT WHEELS WITH GENERAL PURPOSE GREASE, APPLY AN ANTI-SEIZE OR GOOD GENERAL PURPOSE GREASE TO LUBRICATE REAR AX- LES,

3. Blade Care

For best results,mower blades must be kept sharp, The

blades can be sharpened with a few strokes of a file,or on a grinding wheel, We suggest they be sharpened after every

25 hours of mowing, Do not attempt to sharpen while on mower. If you mow in sandy soil check the blades alter each two mowings. The sand wears the blades away rapidly,

a, Blade Replacement

Raise mower to highest position to permit access Io blades,

1, Remove the hex head bolt, iockwasherand flat washer (Fig 12) (tum counterclockwise).

2, Remove and discard old blade,

3., Clean top and bottom of mower housing

4Install new blade with SHARP EDGE DOWN and secure with flat washer, Iockwasher and hex head boll TIGHTEN SECURELY_

ALWAYSUSEGRADES HEAT

TREATED BOLTS TO ATTACH

CHECK BOLTS IN BLADES OCCASION-

_1 BLADES. DO NOTUSE PLATED BOLTS.

ALLY TO MAKE SURE BOLTS ARE

TIGHT. TORQUE BOLTS TO 30-35

FT.-I_BS (41-47 Nm).

14

Page 13 Page 15
Image 14
Page 13 Page 15
Contents Rrftxmrn Performance of Your Tractor Important Equipment PrecautionsPortant Information about the Operation Maintenance Agreement Full 90 DAY Warranty on BatteryAir Cleaner Filter Options AdjustmentsParts,- Replacement/Repair AssemblySlope Instruction To assemble tractoryou wilt need 7116wrenchesKeys Tire Pressure GaugeTerminals Assembly Parts BAG Contents Shown Full Size LocationBattery Steering BushingWear EYE and Face Shield CUT Away View Battery Vent TubeSteering Boot LevelFlat Battery BoltSeat Seat PAN Shoulder \ Bolt WasherAttachment IGNITION\ Height AdjustLight Switch Vent Slots THROTTLE/CHOKE Control ClutchleverFuel Tank CAP/DIPSTICK AIR ScreenOIL Filler Ignition KEY Attachment Clutch Lever Engaged Position1o Read ownersmanuaL MinutePounds 68 KG Operating Your Lawn Tractor and MowerSlow Speed Selection GuideFunction Gearshift Throttle FastTion Move GEARSItlFTTO N Neutral4oPLACE Attachment Clutch Lever in Disengaged Posi Check Brake OperationJAM NUT Brake Must be AdjustedIwith Parking Engaged Nuta Disc BrakeLEAD-ACID Batteries Generate Battery CareLife AIR Screen OIL Filler AIR Cleaner Wing Nuts Cover Engine OIL Filler CAP DipstickAIR Cleaner Body Recommendedsae Viscosity GradesDisengaged Position Gear Shift Lever LEAD-ACID BATrERIESGENERATEParking Brake Engaged Posion CLUTCH/BRAKE 17DRIVE PositionRefer to Starting the Engine Making ANY Adjustm ENT to CarburetorFeeler Gauge JUST- Damage MAY ResultBelt J Listed in the Repair Parts SECTion of this Manual Transaxle Retainer Belt Guide Spring Bracket Engine PulleyKeep Feet Clear from UND Grasp Here HooddashHinge BRACKE1 Grasp HereHighest Pins BracketRETAINERR.H Springsuspention ARM Lift LeverManual Cotter AdjustmentSIDE-TO-SIDE Mower Adjustment LH. PivotCurl Rear Ground Suspension Line Trunnion FRONT-TO-REAR Mower AdjustmentRear Suspension \ ARM Trunnion Lift Bracket NUT FLubrication Chart BearingTrouble Shooting No Ughts Deode Charging WHESpark Position Rcuit3233 C D STD522505101539X Sheet, Instruction,Tractor 126795X OwnersManual 1315 37A Nut, Hex, Lg. Flange, Loc Washer, Black, NylonDecal, Chassis, 5 Speed Spring, Seat, CompressionDrive 143+920037See pages 40 and41 Page STDS51125 21 5479,1Repair Parts C D E F Repair Parts 12 HP 38 Riding Lawn Tractor - Model Number Mower C O E FTransaxle PEERLESS- Model NUMBER-143,920-037 770082 Case, Transaxle 40A 792128 772094 Cover, Transaxte 786026780086 Bearing, Needle 792076 776260 Shaft, Counter 790047143 Revised120 142 35475 Tube, Push rod 43 35310 Housing, Rocker armRef. Pt IncloNoCRAFTSMAN4CYCLEENGINEMODEL143.406152 308A Revised !+!8-9065O886 354O435405 29O 29774Part Name Starter Motor noRT,f 632490Service Notes Service Notes Service Notes 3HP 71-244O7Suggested Guide for Sighting Slopes for Safe Operation When Ordering Repair PARTS, Always Give the Following Sears, Roebuck and Co., Chicag0, IL 60684 U.S.A

917.254611 specifications

The Craftsman 917.254611 is a highly regarded lawn tractor that offers homeowners an efficient and reliable solution for maintaining their lawns. With a user-friendly design and robust features, it stands out as a practical choice for both novice and seasoned garden enthusiasts.

One of the main features of the Craftsman 917.254611 is its powerful engine. The tractor is equipped with a 17.5 HP Briggs & Stratton engine, providing ample power for tackling various yard tasks. This engine is not only strong but also designed for reliability, ensuring that users can depend on it to start easily and perform consistently over time.

The cutting deck is another significant aspect of the Craftsman 917.254611. It boasts a 42-inch deck, which is ideal for maneuvering around obstacles and achieving clean cuts over medium to large-sized lawns. The deck height can be easily adjusted, allowing for six different cutting heights ranging from 1.5 to 4 inches. This flexibility ensures that users can adapt to different grass types and preferences.

In terms of technology and ease of use, the Craftsman 917.254611 incorporates an automatic transmission system. This feature simplifies the driving experience, allowing users to enjoy smooth and seamless operation without the hassle of manual shifting. The comfortable seat and ergonomically designed controls enhance user comfort and reduce fatigue during extended mowing sessions.

Another noteworthy characteristic is the tractor's maneuverability. With a tight turning radius, the Craftsman 917.254611 allows users to navigate around trees, flower beds, and other obstacles effortlessly. This capability is particularly valuable for homeowners with intricate landscaping or tight spaces in their yards.

Maintenance considerations are also addressed with this model. The Craftsman 917.254611 features easy-access components, making routine checks and servicing straightforward for users. The removable deck further aids in cleaning and maintenance tasks, ensuring that the tractor remains in peak condition over its lifespan.

In conclusion, the Craftsman 917.254611 combines power, versatility, and ease of use, making it an exceptional lawn tractor for homeowners. Its strong engine, adjustable cutting deck, and user-friendly features position it as a reliable choice for those seeking an efficient way to maintain their outdoor spaces, providing a tidy and well-kept lawn with minimal effort.
Top Page Image Contents