Craftsman 917.254611 owner manual Manual Cotter, LH. Pivot, Bottom Curl, Adjustment

Page 22

REPAIR AND ADJUSTMENT

BELT

ENGINE

IDLER BELT

EXTENSION

PULLEY

GUIDE

SPRING

...._ IDLER

SHAFT

 

 

LH.

 

ASSEMBLY

23. Mower Drive Belt Removal

NOTE: MOWER BELT INSTALLATION DECAL LOC- ATED ON MOWER HOUSING_

REPLACE ONLY WiTH THE BELTS SPECIFIED IN THIS

MANUAL.

f

COTTER

EXTENSION SPRING

BRAKE__

ROD "--

COTTER PIN

aPlaceattachmentclutchlever in"Disengaged"posi- tion (Fig 30)

b,, Move Attachmentliltle_er (Fig 30).forwardto lower mower to its lowest position_

c_ Roll belt off engine pulley_

d,. Pull belt off both mower deck pulleys._

e._ Springbelt guideaway from idlerpulley and pullbelt off idler pulley

LSlide belt from under extensionspring.

24.Mower Drive Belt Replacement

a,. Slide belt under extension spring(Fig. 33)_

b,_ Place belt on rear side o! both mandrel pulleys

c,. Sprin_ idler belt guide down and place belt around rear s_deo! idler pulley

d.Roll belt over engine pulley

e.Make sure belt is inside all belt guides,,

LH. PIVOT

R,H. PIVOT

BRACKET'

FIGURE 33

LIR'

LEVER

BOTTOM

E_

BOTTOM

OF CURL

 

OF CURL

LINE

FIGURE 34

__

 

NUT "C"

SIDE TO SIDE'_L-'v'_'_PJ _

/

 

ADJUSTMENT

_ i

NUT "B"

TRUNNION _

J

FIGURE 35

NOTE: WHEN INSTALLING A NEW BELT, EXTENSION SPRING MUST BE RETURNED TO LOWER END

OF SLOT (ORIGINAL POSITION) ON ROCK SHAFT ASSEM BLY.

25= Mower Drive Belt Adjustment

Yourtractorhas been manufactured withthe abilityto read- justthe rnowerdrive belt to provideyouwith longer belt life,,

If the attachment clutch lever travels 4-1t2"(11.43 cm) up the slot in the dash before spring resistanceis evident, ad-

justment is necessary, NOTE; CHECK FOR PROPER SPRING TENSION WITH THE ENGINE OFF AND THE

LIFT LEVER IN THE HIGHEST POSITION.

aLower the mower deck for easier access,.

bUsing (2) 7/16"wrenches, removethe bolt, nut & D- Shaped washers (Fig 33- inset).

c.Move extension spring from lower end of slot to up- per end in rockshaft assembly and install bolt, nut & the D-Shaped washers.

dTighten bolt and nut to secure the D-shaped wash- ers (flat side down)..

26.Level Mower Housing

Adjustthe mower while tractor is parkedon level ground or driveway. Make sure tire pressure is correct, fl tires are over or under inflated, you will not properly adjust your mower..

SIDE-TO-SIDE MOWER ADJUSTMENT

a.Depress lift lever plunger and use lift lever to raise mower to maximum cutting height (Fig. 31),

b.Measure heightfrom bottomof cudto groundline at front of mower. Distance"A" shouldbe the same on both sides (Fig, 34),

c.If distance "A"needs to be changed, snap out ac- cess hole cover on L.H, side above footresL Use 11/16" wrench on nuts "B" and "C" at side-to-side adjustment trunnion(Fig=,35),.

d.To raise left side of mower, loosen nut "B" and tighten nut _C",

eTo lower left side of mower, loosen nut "C" and tighten nut "B"..

22

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Rrftxmrn Portant Information about the Operation Important Equipment PrecautionsPerformance of Your Tractor Maintenance Agreement Full 90 DAY Warranty on BatteryAir Cleaner Filter Options AdjustmentsParts,- Replacement/Repair AssemblySlope Instruction To assemble tractoryou wilt need 7116wrenchesKeys Tire Pressure GaugeTerminals Assembly Parts BAG Contents Shown Full Size LocationBattery Steering BushingWear EYE and Face Shield CUT Away View Battery Vent TubeSteering Boot LevelFlat Battery BoltSeat Seat PAN Shoulder \ Bolt WasherAttachment IGNITION\ Height AdjustLight Switch Vent Slots THROTTLE/CHOKE Control ClutchleverFuel Tank CAP/DIPSTICK AIR ScreenOIL Filler Ignition KEY Attachment Clutch Lever Engaged Position1o Read ownersmanuaL MinutePounds 68 KG Operating Your Lawn Tractor and MowerSlow Speed Selection GuideFunction Gearshift Throttle FastTion Move GEARSItlFTTO N Neutral4oPLACE Attachment Clutch Lever in Disengaged Posi Check Brake OperationJAM NUT Brake Must be AdjustedIwith Parking Engaged Nuta Disc BrakeLife Battery CareLEAD-ACID Batteries Generate AIR Screen OIL Filler AIR Cleaner Wing Nuts Cover Engine OIL Filler CAP DipstickAIR Cleaner Body Recommendedsae Viscosity GradesDisengaged Position Gear Shift Lever LEAD-ACID BATrERIESGENERATEParking Brake Engaged Posion CLUTCH/BRAKE 17DRIVE PositionRefer to Starting the Engine Making ANY Adjustm ENT to CarburetorFeeler Gauge JUST- Damage MAY ResultBelt J Listed in the Repair Parts SECTion of this Manual Transaxle Retainer Belt Guide Spring Bracket Engine PulleyKeep Feet Clear from UND Grasp Here HooddashHinge BRACKE1 Grasp HereHighest Pins BracketRETAINERR.H Springsuspention ARM Lift LeverManual Cotter AdjustmentSIDE-TO-SIDE Mower Adjustment LH. PivotCurl Rear Ground Suspension Line Trunnion FRONT-TO-REAR Mower AdjustmentRear Suspension \ ARM Trunnion Lift Bracket NUT FLubrication Chart BearingTrouble Shooting No Ughts Deode Charging WHESpark Position Rcuit3233 101539X Sheet, Instruction,Tractor 126795X OwnersManual STD522505C D 1315 37A Nut, Hex, Lg. Flange, Loc Washer, Black, NylonDecal, Chassis, 5 Speed Spring, Seat, CompressionDrive 143+920037See pages 40 and41 Page STDS51125 21 5479,1Repair Parts C D E F Repair Parts 12 HP 38 Riding Lawn Tractor - Model Number Mower C O E FTransaxle PEERLESS- Model NUMBER-143,920-037 770082 Case, Transaxle 40A 792128 772094 Cover, Transaxte 786026780086 Bearing, Needle 792076 776260 Shaft, Counter 790047143 Revised120 142 35475 Tube, Push rod 43 35310 Housing, Rocker armRef. Pt IncloNoCRAFTSMAN4CYCLEENGINEMODEL143.406152 308A Revised !+!8-9065O886 354O435405 29O 29774Part Name Starter Motor noRT,f 632490Service Notes Service Notes Service Notes 3HP 71-244O7Suggested Guide for Sighting Slopes for Safe Operation When Ordering Repair PARTS, Always Give the Following Sears, Roebuck and Co., Chicag0, IL 60684 U.S.A

917.254611 specifications

The Craftsman 917.254611 is a highly regarded lawn tractor that offers homeowners an efficient and reliable solution for maintaining their lawns. With a user-friendly design and robust features, it stands out as a practical choice for both novice and seasoned garden enthusiasts.

One of the main features of the Craftsman 917.254611 is its powerful engine. The tractor is equipped with a 17.5 HP Briggs & Stratton engine, providing ample power for tackling various yard tasks. This engine is not only strong but also designed for reliability, ensuring that users can depend on it to start easily and perform consistently over time.

The cutting deck is another significant aspect of the Craftsman 917.254611. It boasts a 42-inch deck, which is ideal for maneuvering around obstacles and achieving clean cuts over medium to large-sized lawns. The deck height can be easily adjusted, allowing for six different cutting heights ranging from 1.5 to 4 inches. This flexibility ensures that users can adapt to different grass types and preferences.

In terms of technology and ease of use, the Craftsman 917.254611 incorporates an automatic transmission system. This feature simplifies the driving experience, allowing users to enjoy smooth and seamless operation without the hassle of manual shifting. The comfortable seat and ergonomically designed controls enhance user comfort and reduce fatigue during extended mowing sessions.

Another noteworthy characteristic is the tractor's maneuverability. With a tight turning radius, the Craftsman 917.254611 allows users to navigate around trees, flower beds, and other obstacles effortlessly. This capability is particularly valuable for homeowners with intricate landscaping or tight spaces in their yards.

Maintenance considerations are also addressed with this model. The Craftsman 917.254611 features easy-access components, making routine checks and servicing straightforward for users. The removable deck further aids in cleaning and maintenance tasks, ensuring that the tractor remains in peak condition over its lifespan.

In conclusion, the Craftsman 917.254611 combines power, versatility, and ease of use, making it an exceptional lawn tractor for homeowners. Its strong engine, adjustable cutting deck, and user-friendly features position it as a reliable choice for those seeking an efficient way to maintain their outdoor spaces, providing a tidy and well-kept lawn with minimal effort.
Top Page Image Contents