Weed Eater manual TRACTOR - - MODEL NUMBER WE12538J, Schematic

Page 26

TRACTOR - - MODEL NUMBER WE12538J

TRACTOR - - MODEL NUMBER WE12538J

SCHEMATIC

RED

BLACK

BATTERY

	A	RED
	A
AMMETER			FUSE
AMMETER
(OPTIONAL)
		WHITE
RED	B	S
		S
		M	CLUTCH / BRAKE
	G		CLUTCH / BRAKE
	G	A1	(PEDAL UP)
	L	A2
BLACK	IGNITION
BLACK	SWITCH
	SWITCH
			BLACK
			BLACK
			HOUR
			METER
			(OPTIONAL)
			FUEL
		BLUE	LINE

		RED	M
			M
			STARTER
			BLACK
		SOLENOID
		WHITE
			SEAT SWITCH
			(NOT OCCUPIED)
	WHITE
		BLACK	BLACK
		ATT'MENT CLUTCH	GROUNDING
	BLACK	(CLUTCH OFF)	GROUNDING
	BLACK	(CLUTCH OFF)	CONNECTOR
			CONNECTOR

				SPARK
BLACK		IGNITION		PLUG
		UNIT		GAP
		UNIT	(2 PLUGS ON
			(2 PLUGS ON
			TWIN CYL. ENGINES)
	CHARGING SYSTEM OUTPUT		28 VOLTS AC MIN. @ 3600 RPM
	3 AMP DC @ 3600 RPM		(CHARGING SYSTEM DISCONNECTED)

	FUEL SHUT-OFF SOLENOID	RED
	FUEL SHUT-OFF SOLENOID
	(IF SO EQUIPPED)	LIGHTING SYSTEM OUTPUT
	(IF SO EQUIPPED)		DIODE

	ORANGE	5 AMP AC @ 3600 RPM
	ORANGE	5 AMP AC @ 3600 RPM

ALTERNATOR

14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”

OFF	M+G+A1	NONE
RUN/LIGHT	B+A1	A2+L

NOTE

YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS

WILL BECOME THEIR BRIGHTEST.

WIRING INSULATED CLIPS

BROWN

BLACK

HEADLIGHTS

NON-REMOVABLE

CONNECTIONS

REMOVABLE

CONNECTIONS

RUN	B+A1	NONE
START	B + S + A1	NONE

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.

27

Image 26

Contents MODEL NO. WE12538J 12.5HP 38 Inch LawnTractor I. GENERAL OPERATION SAFETY RULESIV. SERVICE II. SLOPE OPERATIONSAFETY RULES Safe Operation Practices for Ride-OnMowersCUSTOMER RESPONSIBILITIES TABLE OF CONTENTSPRODUCT SPECIFICATIONS Seat UNASSEMBLED PARTSSteering Wheel KeysTO REMOVE TRACTOR FROM CARTON ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY BEFORE REMOVING TRACTOR FROM SKIDINSTALL SEAT See Fig HOW TO SET UP YOUR TRACTORCHECK BATTERY See Fig CHECK DECK LEVELNESS CHECKLISTCHECK TIRE PRESSURE CHECK FOR PROPER POSITION OF ALL BELTSOPERATION KNOW YOUR TRACTOR TO SET PARKING BRAKE See Fig HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig STOPPING See FigTO OPERATE ON HILLS BEFORE STARTING THE ENGINETO OPERATE MOWER See Fig. TO TRANSPORTMOWING TIPS TO START ENGINE See Fig¿LUBRICATION CHART CUSTOMER RESPONSIBILITIESGENERAL RECOMMENDATIONS MAINTENANCE SCHEDULETIRES TRACTORBRAKE OPERATION OPERATOR PRESENCE SYSTEMV-BELTS ENGINEBATTERY TRANSAXLE COOLINGAIR FILTER See Fig CLEAN AIR SCREENENGINE COOLING FINS See Fig SPARK PLUGS CLEANINGMUFFLER IN-LINEFUEL FILTER See FigTO REMOVE MOWER See Fig SERVICE AND ADJUSTMENTSTO INSTALL MOWER See Fig TO LEVEL MOWER HOUSING TO REPLACE MOWER BLADE DRIVE BELT See FigTO START ENGINE WITH A WEAK BATTERY See Fig TO ADJUST BRAKE See FigTO ADJUST STEERING WHEEL ALIGNMENT TO REPLACE MOTION DRIVE BELT See FigINTERLOCKS AND RELAYS REPLACING BATTERY See Figs. 25 ANDTO REPLACE HEADLIGHT BULB TO REPLACE FUSEENGINE TO ADJUST THROTTLE CONTROL CABLE See Fig TO REMOVE HOOD AND GRILL ASSEMBLY See FigTO ADJUST CARBURETOR FUEL SYSTEM STORAGEOTHER ENGINE OILCAUSE TROUBLESHOOTING POINTSPROBLEM CORRECTIONTRACTOR - - MODEL NUMBER WE12538J SCHEMATICREPAIR PARTS ELECTRICALKEY PART NO. NO. DESCRIPTION CHASSIS PART DESCRIPTIONDRIVE DRIVE 42 37 37 36 STEERING38 63 11 26 28STEERING 8113 OPTIONAL EQUIPMENT Spark ArresterENGINE 170551 Control Th/ch FlagSEAT DECALS WHEELS & TIRESMOWER LIFT 11 19 13 31 32 13 159460 Wire Asm Inner/Sprg w/plungerMOWER LIFT MOWER DECK MOWER DECK SERVICE NOTES LIMITED WARRANTY NEW PEERLESS GEAR POWER TRAIN COMPONENTS SERVICEWARRANTY POLICYONLY RIDE UP AND DOWN HILL Page Engine continues to run