Weed Eater WE12538J manual How To Set Up Your Tractor, Assembly, CHECK BATTERY See Fig

Page 7
HOW TO SET UP YOUR TRACTOR

ASSEMBLY

HOW TO SET UP YOUR TRACTOR

CHECK BATTERY (See Fig. 2)

•Lift seat pan to raised position and open battery box door.

•If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in CUSTOMER RESPONSIBILITIES section of this manual for charging instructions).

SEAT PAN

LABEL

BATTERY

BOX DOOR

TERMINAL

TERMINAL

FIG. 2

INSTALL SEAT (See Fig. 3)

Adjust seat before tightening adjustment bolt.

•Remove adjustment bolt, lock washer and flat washer securing seat to cardboard packing and set aside for assembly of seat to tractor.

•Pivot seat upward and remove from the cardboard packing. Remove the cardboard packing and discard.

•Place seat on seat pan so head of shoulder bolt is positioned over large slotted hole in pan.

•Push down on seat to engage shoulder bolt in slot and pull seat towards rear of tractor.

•Pivot seat and pan forward and assemble adjustment bolt, lockwasher and flat washer loosely. Do not tighten

•Lower seat into operating position and sit on seat.

•Slide seat until a comfortable position is reached which allows you to press clutch/brake pedal all the way down.

•Get off seat without moving its adjusted position.

•Raise seat and tighten adjustment bolt securely.

SEAT

SEAT PAN

SHOULDER

BOLT

FLAT WASHER

LOCK WASHER

ADJUSTMENT

BOLT

FIG. 3

NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid.

TO ROLL TRACTOR OFF SKID (See Operation section, page 10, for location and function of controls)

•Press lift lever plunger and raise attachment lift lever to its highest position.

•Release parking brake by depressing clutch/brake pedal.

•Place gearshift lever in neutral (N) position.

•Roll tractor forward off skid.

•Remove banding holding deflector shield up against tractor.

7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents MODEL NO. WE12538J 12.5HP 38 Inch LawnTractor II. SLOPE OPERATION SAFETY RULESIV. SERVICE I. GENERAL OPERATIONSafe Operation Practices for Ride-OnMowers SAFETY RULES PRODUCT SPECIFICATIONS TABLE OF CONTENTS CUSTOMER RESPONSIBILITIES Keys UNASSEMBLED PARTSSteering Wheel SeatBEFORE REMOVING TRACTOR FROM SKID ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY TO REMOVE TRACTOR FROM CARTONCHECK BATTERY See Fig HOW TO SET UP YOUR TRACTORINSTALL SEAT See Fig CHECK FOR PROPER POSITION OF ALL BELTS CHECKLISTCHECK TIRE PRESSURE CHECK DECK LEVELNESSOPERATION KNOW YOUR TRACTOR STOPPING See Fig HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig TO SET PARKING BRAKE See FigTO TRANSPORT BEFORE STARTING THE ENGINETO OPERATE MOWER See Fig. TO OPERATE ON HILLSTO START ENGINE See Fig MOWING TIPSMAINTENANCE SCHEDULE CUSTOMER RESPONSIBILITIESGENERAL RECOMMENDATIONS ¿LUBRICATION CHARTOPERATOR PRESENCE SYSTEM TRACTORBRAKE OPERATION TIRESTRANSAXLE COOLING ENGINEBATTERY V-BELTSENGINE COOLING FINS See Fig CLEAN AIR SCREENAIR FILTER See Fig IN-LINEFUEL FILTER See Fig CLEANINGMUFFLER SPARK PLUGSTO INSTALL MOWER See Fig SERVICE AND ADJUSTMENTSTO REMOVE MOWER See Fig TO REPLACE MOWER BLADE DRIVE BELT See Fig TO LEVEL MOWER HOUSINGTO REPLACE MOTION DRIVE BELT See Fig TO ADJUST BRAKE See FigTO ADJUST STEERING WHEEL ALIGNMENT TO START ENGINE WITH A WEAK BATTERY See FigTO REPLACE FUSE REPLACING BATTERY See Figs. 25 ANDTO REPLACE HEADLIGHT BULB INTERLOCKS AND RELAYSTO ADJUST CARBURETOR TO REMOVE HOOD AND GRILL ASSEMBLY See FigENGINE TO ADJUST THROTTLE CONTROL CABLE See Fig ENGINE OIL STORAGEOTHER FUEL SYSTEMCORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSESCHEMATIC TRACTOR - - MODEL NUMBER WE12538JELECTRICAL REPAIR PARTSKEY PART NO. NO. DESCRIPTION CHASSIS DESCRIPTION PARTDRIVE TRACTOR - - MODEL NUMBER WE12538J 11 26 28 STEERING38 63 42 37 37 36TRACTOR - - MODEL NUMBER WE12538J ENGINE OPTIONAL EQUIPMENT Spark Arrester8113 Control Th/ch Flag 170551SEAT WHEELS & TIRES DECALSMOWER LIFT 11 19 13 31 32 13 MOWER LIFT Wire Asm Inner/Sprg w/plunger159460 MOWER DECK TRACTOR - - MODEL NUMBER WE12538J SERVICE NOTES LIMITED WARRANTY POLICY SERVICEWARRANTY NEW PEERLESS GEAR POWER TRAIN COMPONENTSONLY RIDE UP AND DOWN HILL Page Engine continues to run
Top Page Image Contents