Weed Eater WE12538J manual Table Of Contents, Product Specifications, Customer Responsibilities

Page 4
PRODUCT SPECIFICATIONS

PRODUCT SPECIFICATIONS

GASOLINE CAPACITY

1.25 GALLONS

AND TYPE:

UNLEADED REGULAR

 

 

OIL TYPE (API-SF-SJ):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

 

 

 

OIL CAPACITY:

3 PINTS

 

 

 

SPARK PLUG:

CHAMPION RJ19LM

(GAP: .030")

 

 

 

 

 

GROUND SPEED (MPH):

FORWARD:

 

 

1st

1.1

 

2nd

2.2

 

3rd

3.3

 

4th

4.4

 

5th

4.9

 

REVERSE:

1.4

 

 

 

TIRE PRESSURE:

FRONT:

14 PSI

 

REAR:

12 PSI

 

 

CHARGING SYSTEM:

3 AMPS BATTERY

 

5 AMPS HEADLIGHTS

 

 

 

BATTERY:

AMP/HR:

25

 

MIN. CCA:

190

 

CASE SIZE:

U1R

 

 

BLADE BOLT TORQUE:

27-35 FT. LBS.

 

 

 

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained tech- nicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Customer Responsibili- ties” and “Storage” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-cov- ered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department (See RE- PAIR PARTS section of this manual).

TABLE OF CONTENTS

SAFETY RULES

2-3

SERVICE AND ADJUSTMENTS

19-23

PRODUCT SPECIFICATIONS

4

STORAGE

24

CUSTOMER RESPONSIBILITIES

4, 14-18

TROUBLESHOOTING

25-26

ASSEMBLY

6-8

REPAIR PARTS

28-43

OPERATION

9-13

WARRANTY

45-46

MAINTENANCE SCHEDULE

14

 

 

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents MODEL NO. WE12538J 12.5HP 38 Inch LawnTractor SAFETY RULES IV. SERVICEI. GENERAL OPERATION II. SLOPE OPERATIONSAFETY RULES Safe Operation Practices for Ride-OnMowersPRODUCT SPECIFICATIONS TABLE OF CONTENTSCUSTOMER RESPONSIBILITIES UNASSEMBLED PARTS Steering WheelSeat KeysASSEMBLY TOOLS REQUIRED FOR ASSEMBLYTO REMOVE TRACTOR FROM CARTON BEFORE REMOVING TRACTOR FROM SKIDCHECK BATTERY See Fig HOW TO SET UP YOUR TRACTORINSTALL SEAT See Fig CHECKLIST CHECK TIRE PRESSURECHECK DECK LEVELNESS CHECK FOR PROPER POSITION OF ALL BELTSOPERATION KNOW YOUR TRACTOR HOW TO USE YOUR TRACTOR TO ADJUST MOWER CUTTING HEIGHT See FigTO SET PARKING BRAKE See Fig STOPPING See FigBEFORE STARTING THE ENGINE TO OPERATE MOWER See Fig.TO OPERATE ON HILLS TO TRANSPORTMOWING TIPS TO START ENGINE See FigCUSTOMER RESPONSIBILITIES GENERAL RECOMMENDATIONS¿LUBRICATION CHART MAINTENANCE SCHEDULETRACTOR BRAKE OPERATIONTIRES OPERATOR PRESENCE SYSTEMENGINE BATTERYV-BELTS TRANSAXLE COOLINGENGINE COOLING FINS See Fig CLEAN AIR SCREENAIR FILTER See Fig CLEANING MUFFLERSPARK PLUGS IN-LINEFUEL FILTER See FigTO INSTALL MOWER See Fig SERVICE AND ADJUSTMENTSTO REMOVE MOWER See Fig TO LEVEL MOWER HOUSING TO REPLACE MOWER BLADE DRIVE BELT See FigTO ADJUST BRAKE See Fig TO ADJUST STEERING WHEEL ALIGNMENTTO START ENGINE WITH A WEAK BATTERY See Fig TO REPLACE MOTION DRIVE BELT See FigREPLACING BATTERY See Figs. 25 AND TO REPLACE HEADLIGHT BULBINTERLOCKS AND RELAYS TO REPLACE FUSETO ADJUST CARBURETOR TO REMOVE HOOD AND GRILL ASSEMBLY See FigENGINE TO ADJUST THROTTLE CONTROL CABLE See Fig STORAGE OTHERFUEL SYSTEM ENGINE OILTROUBLESHOOTING POINTS PROBLEMCAUSE CORRECTIONTRACTOR - - MODEL NUMBER WE12538J SCHEMATICREPAIR PARTS ELECTRICALKEY PART NO. NO. DESCRIPTION CHASSIS PART DESCRIPTIONDRIVE TRACTOR - - MODEL NUMBER WE12538J STEERING 38 6342 37 37 36 11 26 28TRACTOR - - MODEL NUMBER WE12538J ENGINE OPTIONAL EQUIPMENT Spark Arrester8113 170551 Control Th/ch FlagSEAT DECALS WHEELS & TIRESMOWER LIFT 11 19 13 31 32 13 MOWER LIFT Wire Asm Inner/Sprg w/plunger159460 MOWER DECK TRACTOR - - MODEL NUMBER WE12538J SERVICE NOTES LIMITED WARRANTY SERVICE WARRANTYNEW PEERLESS GEAR POWER TRAIN COMPONENTS POLICYONLY RIDE UP AND DOWN HILL Page Engine continues to run
Top Page Image Contents