Weed Eater 187637 Table Of Contents, Product Specifications, Customer Responsibilities, 9-13

Page 4
PRODUCT SPECIFICATIONS

PRODUCT SPECIFICATIONS

GASOLINE CAPACITY

1.25 GALLONS

AND TYPE:

UNLEADED REGULAR

 

 

OIL TYPE (API-SF-SJ):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

OIL CAPACITY:

W/Filter: 62 OZ.

 

W/O Filter: 55 OZ.

SPARK PLUG:

CHAMPION RN4C

(GAP: .030")

 

 

GROUND SPEED (MPH):

FORWARD:

 

 

1st

1.1

 

2nd

2.2

 

3rd

3.3

 

4th

4.4

 

5th

4.9

 

REVERSE:

1.4

 

 

 

TIRE PRESSURE:

FRONT:

14 PSI

 

REAR:

12 PSI

 

 

CHARGING SYSTEM:

3 AMPS BATTERY

 

5 AMPS HEADLIGHTS

 

 

 

BATTERY:

AMP/HR:

28

 

MIN. CCA:

230

 

CASE SIZE:

U1R

BLADE BOLT TORQUE: 27-35 FT. LBS.

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenance” and “Storage” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department (See REPAIR PARTS section of this manual).

TABLE OF CONTENTS

SAFETY RULES

2-3

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

6-8

OPERATION

9-13

MAINTENANCE SCHEDULE

14

MAINTENANCE

14-18

SERVICE AND ADJUSTMENTS

19-23

STORAGE

24

TROUBLESHOOTING

25-26

REPAIR PARTS

28-43

WARRANTY

45

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents MODEL NO. WET1338B 13 HP 38 Inch Lawn Tractor SAFETY RULES IV. SERVICESafe Operation Practices for Ride-On Mowers I. GENERAL OPERATIONNever carry passengers or children even with the blades off TABLE OF CONTENTS PRODUCT SPECIFICATIONSCUSTOMER RESPONSIBILITIES 9-13UNASSEMBLED PARTS Steering WheelSeat KeysASSEMBLY TOOLS REQUIRED FOR ASSEMBLYTO REMOVE TRACTOR FROM CARTON BEFORE REMOVING TRACTOR FROM SKIDINSTALL SEAT See Fig HOW TO SET UP YOUR TRACTORCHECK BATTERY See Fig CHECK TIRE PRESSURE CHECK DECK LEVELNESSCHECK FOR PROPER POSITION OF ALL BELTS CHECK BRAKE SYSTEMOPERATION KNOW YOUR TRACTOR HOW TO USE YOUR TRACTOR TO ADJUST MOWER CUTTING HEIGHT See FigTO SET PARKING BRAKE See Fig TO USE THROTTLE CONTROL See FigBEFORE STARTING THE ENGINE TO OPERATE MOWER See FigTO OPERATE ON HILLS TO TRANSPORTMOWING TIPS TO START ENGINE See FigMAINTENANCE LUBRICATION CHARTGENERAL RECOMMENDATIONS BEFORE EACH USETRACTOR BRAKE OPERATIONTIRES OPERATOR PRESENCE SYSTEMBATTERY ENGINEV-BELTS TRANSAXLE COOLINGENGINE COOLING FINS See Fig CLEAN AIR SCREENAIR FILTER See Fig CLEANING MUFFLERSPARK PLUGS IN-LINE FUEL FILTER See FigSERVICE AND ADJUSTMENTS TO INSTALL MOWER See FigTO REMOVE MOWER See Fig Depress clutch/brake pedal fully and set parking brakeTO REPLACE MOWER BLADE DRIVE BELT See Fig TO LEVEL MOWER HOUSINGBOTH FRONT LINKS MUST BE EQUAL IN LENGTH TO CHECK AND ADJUST BRAKE See Fig TO ADJUST STEERING WHEEL ALIGN MENTTO REPLACE MOTION DRIVE BELT See Fig FRONT WHEEL TOE-IN/CAMBERREPLACING BATTERY See Figs. 25 and TO START ENGINE WITH A WEAK BATTERY See FigTO REMOVE WHEEL FOR REPAIRS See Fig TO REMOVE HOOD AND GRILL ASSEMBLY See Fig TO ADJUST THROTTLE CONTROL CABLE See FigTO ADJUST CARBURETOR TO REPLACE HEADLIGHT BULBSTORAGE OTHERFUEL SYSTEM ENGINE OILTROUBLESHOOTING POINTS PROBLEMCAUSE CORRECTIONEngine continues to run SCHEMATIC TRACTOR - - MODEL NUMBER WET1338BELECTRICAL REPAIR PARTS2441 PART DESCRIPTION145 CHASSISchassis-pl.lt23 REPAIR PARTS 202 DRIVEdrive-saddle24 REPAIR PARTS 8546 STEERING1529 REPAIR PARTS OPTIONAL EQUIPMENT Spark Arrester ENGINE170864 Control Th/ch FlagSEAT DECALS WHEELS & TIRESMOWER LIFT lift-rh.1piece3REPAIR PARTS MOWER DECK 38deck-manual1REPAIR PARTS SERVICE NOTES LIMITED WARRANTY LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS T E C U M S EHSERVICE WARRANTYONLY RIDE UP AND DOWN HILL NOT ACROSS HILL 15 DEGREES MAX FOLDALONG THIS01029-weedeater
Top Page Image Contents