Sears 917.258542 owner manual Troubleshooting Points, Problemcause, Correction

Page 28

TROUBLESHOOTING POINTS

PROBLEMCAUSE

CORRECTION

l

......... '""," i 'M"'

Engine continues to run

when operator leaves seat with attachment clutch

engaged

Poor cut - uneven

i

, ii iiii

i ,,

,

,,i ......,..............

1 Faults'operator-safety presence control system

1 Worn, bent or loose blade,.

2.Mower deck not level

3, Buildup of grass, leaves, and trash under mower

4Bent blade mandrel

5Clogged mower deck vent holes from buildup of grass, leaves, and trash around msndre{s.

,

,

I"

i

ii

1Check wiring, switches and connecLions if nor corrected, contact an authorized ssrvt_e center/ department

tReplace blade Tighten blade bolt

2 Level mower deck.

3Clean underside of mower housing

4Replace blade mandre!

5Clean around mandrets to open vent holes

Mower blades will not

1

Obstruction

in clutch mechanism

rotate

2,

Worn/damaged

mower dr_ve be_t

 

3

Frozen

idler

pulley

 

4

Frozen

blade

mandrel

,,I'H

1Remove obstruction

2Replace mower drive belt

3Replace ldter pulley

4Replace blade mandrel

Poor grass discharge

.... i

1Engine speed tee slew 2, Travel speed too fast 3 Wet grass

4 Mower deck not level

5.Low/uneven tire air pressure, 6, Worn, bent orloose blade

7Buildup of grass, leaves and trash under mower 8, Mower drive belt worn

9Blades improperfy installed

I0 improper blades used.

1 t Clogged mower deck vent holes from buildup of grass, reaves, and trash around mandrels

1Place throttle controt in "FAST" position

2Shift toslower speed

3Allow grass to dry before mowing

4Level mower deck

5Checktires for proper air pressure

6.Replace/sharpen blade Tighten blade bolt

7Clean underside of mower housing

8Reptace mower drive belt.

9_ Reinstall blades sharp edge dbwn.

10Replace with blades listed in this mbdual

11Clean around mandrels to open vent holes

Headlight(s) not working

1

Switch

is "OFF"

1

Turn switch "ON"

(if so equipped)

2

Bulb(s)

burned out

2

Reptace

bulb(s)

 

 

3

Faulty

light switch

3

Check/replace

light switch

 

4..

Loose

or damaged wiring

4

Check wiring and connections

 

5o

B!own

fuse

5

Replace

fuse

 

 

i

 

 

 

 

i

i

Battery will not charge

Engine "backfires"

when turning engine

"OFF"

I Bad battery celt(s)

2., Poor cable connections

3.Fautty regulator (if so equipped)

4Faulty alternator.

Engine throttle control not set at "SLOW" position for 30 seconds before stopping engine

1_ Replace battery

2.Chectdcfean all connections

3Replace regulator

4Replace affernator.

Move throtlle control to "SLOW" position and allow to idle for 30 seconds before stopl_lng engine

28

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Model Number 917.258542 Ownersmanual For Consumer Assistance HOT LINE, Call this Toll Free NumberSafe Operation Practices for Ride-On Mowers III. ChildrenMaintenance Agreement Index Attachments Engine MaintenancePerformance Contents Hardware Parts Bag contents shown ful! sizeParts bag contents not shown full size PackConnect Battery See Figs Assemble Extension Shaft and BootInstall Steering Wheel Unpack CartonCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemAssembly Install Mulcher Plate See FigsTo Convert to Bagging or Discharging Shoulder BoltOperati Operation Know Your TractorOperation To Move Forward and BackwardOPERAT!O To Operate Mower See FigTo Transport To Operate on HillsTo Start Engine See Fig Mulching Mowing TipsCustomer Lubrication ChartBefore Each USE Battery TractorBrake Operation TiresCustomer LubricationClean AIR Screen Clean AIR INTAKE/COOLINGCusto ResponEngihe OiL Filter See Fig IN-LINE Fuel Filter See FigAdjustments To Install Mower See FigTo Remove Mower See Fig If AN Attachment Other thanTo Level Mower Housing Rvice AN AdjustmentsAdjust the mower while tractor is parked on level ground or To Adjust Brake See Fig To Replace Mower Blade Drive BeltTo Replace Motion Drive Belt With Parking Brake EngagedService To Adjust Steering Wheel AlignmentTransaxle Shifter Linkage and AD- Justment See Figs Front Wheel TOE-IN/CAMBERService AdjustmentsTo Replace Fuse To Replace Headlight BulbService Adjustments To Adjust Throttle Control CableTo Adjust Carburetor See Fig Acceleration TestEngine OIL Fuel SystemCylinders Problem Troubleshooting PointsCause Correction Problemcause Troubleshooting PointsCorrection SEA,SW,TOH PoSmONOptional LineElectrical NO, NO, Description KEY PartUNC Chassis and Enclosures KEY Part Description CHASS1SANDENCLOSURESStlt 88 87 121Drive STLSteering Assembly FF224035X Repair Parts Seat Assembly151300 DecalsWheels & Tires Engine Optional Equipment Spark ArresterREPAmR Parts Tractor --MODEL Number Mower Lift 549150 \ 161718Mower Lift KEY Part NO. no105 Mower Deck113 111 114 Torsion Brakes Mower Deck KEY PartTUV Peerless Transaxle Model Number 930-057A Part REF Part Description 792075Blower Housing Baffles Kohler Engine Model Number CV15S, Type Number PS-41526AIR Intake Engine Controls JBlower Housing and Baffles KEY Part Description AIR Intake Engine Controls KEY Part NO. noCrankshaft KEY Part Description KEY Part NO. noCylinder HEAD, Valve and Breather Kohler ENGINE- Model Number CV15S, Type Number PS-415262227 Not Illustrated OIL PAN / Lubrication J Ignition ELECTRICAL,,IStarting System 231Ignition Electrical KEY Part Description Not IllustratedOIL PAN 1 Lubrication Crankcase KEY Part NO. noPage ItA OporaoyourTupanO0owntheaceosocornotI Owners ManualINFORMATION Following Information

917.258542 specifications

The Sears 917.258542 is a notable model in the world of outdoor power equipment, specifically engineered for lawn care enthusiasts and homeowners seeking reliable performance. This lawn mower is recognized for its robust design and a plethora of features that make lawn maintenance a straightforward task.

One of the standout characteristics of the Sears 917.258542 is its powerful engine. Equipped with a reliable Briggs & Stratton engine, it delivers excellent cutting performance, allowing for efficient grass cutting across different terrains. The engine is designed for easy starting and durability, ensuring that users can rely on it season after season.

The cutting deck is another key feature, typically ranging from 20 to 21 inches, making it suitable for both small and medium-sized lawns. The deck design allows for efficient grass clipping with multiple height adjustment settings. This adjustability lets users maintain their lawn at the desired height, fostering a healthier yard. Furthermore, the mower's deck may come with a mulching feature, which is particularly beneficial for returning nutrients back to the soil.

Innovation is imbued within the Sears 917.258542 through its user-friendly controls. Operators can easily adjust the speed and cutting height, providing customizable performance tailored to individual needs. The mower's ergonomic design enhances comfort during operation, reducing fatigue during extensive mowing sessions.

Another important technology incorporated in the Sears 917.258542 is its self-propulsion system. This feature allows users to navigate the mower across varied landscapes without excessive physical exertion. The self-propelling mechanism streamlines mowing, allowing the mower to advance at a pace controlled by the user.

Durability has not been overlooked in this model. Made with high-quality materials, the Sears 917.258542 is built to withstand the rigors of regular use, including harsh weather conditions. Maintenance is simplified with easy access to the air filter and spark plug, which helps to prolong the life of the mower.

In conclusion, the Sears 917.258542 emerges as a reliable and efficient solution for lawn care. Its powerful engine, adjustable cutting deck, user-friendly controls, self-propulsion feature, and durable construction make it an intelligent choice for anyone looking to keep their lawn in pristine condition. Whether battling tall grass or maneuvering around obstacles, this mower is designed to meet the diverse needs of home lawn care.
Top Page Image Contents