Sears 917.271051 To Adjust Brake, To Replace Motion Drive Belt, Belt Removal, Belt Installation

Page 22

TO REPLACE MOWER BLADE DRIVE BELT

The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake.

BELT REMOVAL-

Remove mower from tractor (See "TO REMOVE MOWER" in this section of

this manual).

Work belt off both mandrel pulleys and idler pulleys.

Pull belt away from mower.

BELT INSTALLATION -

Install new belt in reverse order of removal.

Make sure belt is in all pulley grooves and inside all belt guides.

Install mower in reverse order of removal instructions.

Mandrel

Road test tractor for proper stopping distance as stated above. Readjust if necessary. If stopping distance is still greater than six (6) feet in highest gear, further maintenance is neces- sary. Contact your nearest authorized service center/department.

With Parking Brake "Engaged"

Jam Nut

Operating

Arm

o

Mandr_

Pulley

TO ADJUST BRAKE

Your tractor is equipped with an adjust- able brake system which is mounted on the right side of the transaxle.

If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted.

Depress clutch/brake pedal and engage parking brake.

Measure distance between brake

operating arm and nut "A" on brake rod.

If distance is other than 1-1/2", loosen jam nut and turn nut "A" until distance becomes 1-1/2". Retighten jam nut against nut "A".

TO REPLACE MOTION DRIVE BELT

Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest.

Remove mower (See "TO REMOVE MOWER" in this section of this

manual.)

Remove belt from stationary idler and clutching idler.

Pull belt slack toward rear of tractor.

Remove belt upwards from transaxle pulley by deflecting belt keepers.

Pull belt toward front of tractor and remove downwards from around engine pulley.

Install new belt by reversing above procedure.

Clutchin

Transaxle

22

Image 22
Contents RRIIFTSMAN Sears Craftsman Help LineLimitedtwoyearwarrantyoncraftsmanridingequipmentparts Limited 90 DAY Warranty on BatteryDo not General OperationSlope Operation ChildrenService Mower blades are sharp and can cut3ROUND Product SpecificationsRepair Agreement Steering Wheel Keys Video Cassette Slope SheetBefore Rolling Tractor OFF Skid HOW to SET UP Your TractorTo Remove Tractor from Carton Unpack CartonTo Drive Tractor OFF Skid Install SeatSee Operation section for location Function of controls Install Mulcher Plate Check for Proper Position of ALL BeltsH L Knowyour Tractor HOW to USE Your Tractor StoppingTo Operate on Hills To Adjust Gauge WheelsTo Operate Mower Addgasoline Towing Carts and Other AttachmentsBefore Starting the Engine Check Engine OIL LevelMowing Tips Mulching Mowing TipsBefore Each USE Lubrication ChartGeneral Recommendations ZerkZerkOperator Presence System Brake OperationTires Blade CareTransaxle Cooling Clean AIR ScreenClean AIR INTAKE/COOLING Areas BeltsMuffler SparkplugsIN-LINE Fuel Filter AIR FilterTractor CleaningTo Install Mower To Remove MowerTo Level Mower Housing SIDE-TO-SIDE AdjustmentTo Replace Motion Drive Belt To Adjust BrakeBelt Installation Belt RemovalTransaxlegearshiftlever To Adjust Steering Wheel AlignmentTo Start Engine with a Weak Battery Front Wheel TOE-IN/CAMBERTo Replace Headlight Bulb To Remove Hoodand Grill AssemblyReplacing Battery Interlocks and RelaysEngine To Adjust Throttle ControlTo Adjust Carburetor CableAcceleration Test Engine Fuel System BatteryTractor Drain oil with engine warm and replaCorrection Troubleshooting Chart ProblemCause Troubleshooting Chart Problemcause CorrectionTroubleshooting Chart Problem Cause87A Tractor - Model Number SchematicFss Tractor - Model Number Electrical 146147 Tractor - Model Number Electrical163465 166180 Fuse 15AMP 27 73510400 Nut Keps Hex 1/4-20UricTractor - Model Number 917.271051 Chassis and Enclosures Tractor - Model Number Chassis and Enclosures KEY Part DescriptionTractor - Model Number Ground Drive 130804 Rod, Brake 150360 Nut, Nylock STD541237 158391X428 106933X166231 Bolt 145Tractor - Model Number 917.271051 Steering Assembly Tractor - Model Number Steering Assembly KEY Part NO. NO.DESCRIPTIONOptional Equipment Tractor - Model Number Engine40t Spark Arrester162156 17720410Tractor - Model Number Seat Assembly Tractor --MODEL Number Decals Wheels & TiresTractor - Model Number Lift Assembly KEY Part NO. NO,DESCRIPTION Shaft Asm. Lift 105767X PinGrooveA/,J Tractor --MODEL Number Mower DeckTractor - Model Number Mower Deck KEY Part NO. noPage Ring Gear Part DescriptionGiven in U.S Crankshaft Fuel System Cylinder HEAD, Valve and Breather Io3 Crankshaft KEY Part Description Blower Housing and Baffles KEY Part DescriptionAIR Intake KEY Part Description Engine Controls KEY Part NO. NO,DESCRIPTION12-757-03-S Flange M6xl.012-041-0t-S 24-186-03-SKEY Part NO. no Ignition ! Electrical Crankcase KEY Part DescriptionOIL PAN / Lubrication KEY Part Description Starting System KEY Part NO. NO,DESCRIPTIONPage Page Page Sighting Only Ride UP and Down HillNot Across Hill AWL8004694663 SU-HOGAR