Sears 917.271051 owner manual Troubleshooting Chart Problem, Correction, Cause

Page 28

TROUBLESHOOTING

 

CHART

 

 

 

 

 

PROBLEM

CAUSE

 

 

 

 

 

 

 

Will

not start

Out of

fuel.

 

 

 

 

 

Engine

not

"CHOKED"

 

 

 

properly.

 

 

 

 

 

 

 

Engine

flooded.

 

 

 

 

Bad

spark

 

plug.

 

 

 

Dirty

air filter.

 

 

 

 

Dirty

fuel

 

filter.

 

 

 

 

Water

in fuel.

 

 

 

 

Loose

or

damaged

wiring.

 

 

Carburetor

 

out

of adjustmenl

 

 

Engine valves

out of

 

 

 

adjustment.

 

 

 

Hard

to start

Dirty

air

filter.

 

 

 

 

Bad

spark

 

plug.

 

 

 

Weak

or

dead

battery.

 

 

Dirty

fuel

 

filter.

 

 

 

 

Stale

or

dirty fuel.

 

 

 

Loose or damaged wiring.

 

 

Carburetor

 

out

of adjustmenl

 

 

Engine valves

out of

 

 

 

adjustment.

 

 

 

Enginewill not

Clutch/brake

pedal

not

turn

over

 

depressed.

 

 

 

 

 

Attachment

clutch

is

 

 

 

engaged.

 

 

 

 

 

 

 

• Weak or dead battery.

 

 

Blown

fuse.

 

 

 

 

Corroded

 

battery

terminals.

 

 

Loose

or

damaged

wiring.

 

 

Faulty

ignition

switch.

 

 

Faulty

solenoid

or

starter.

 

 

Faulty

operator presence

 

 

 

switch(es).

 

 

 

Engine clicks but • Weak or dead battery. will not start

Corroded battery terminals.

Loose or damaged wiring.

Faulty solenoid or starter.

CORRECTION

Fill fuel tank.

See "TO START ENGINE" in Operation section.

Wait several minutes before attempting to start.

Replace spark plug.

Clean/replace air filter.

Replace fuel filter.

Drain fuel tank and carburetor, refill tank with

fresh gasoline and replace fuel filter.

Check all wiring.

See "To Adjust Carburetor"

in Service Adjustments section.

Contact an

authorized service center/ department.

Clean/replace air filter.

Replace spark plug.

Recharge or replace battery.

Replace fuel filter.

Drain fuel tank and refill with fresh gasoline.

Check all wiring.

See "To Adjust Carburetor"

in Service Adjustments section.

Contact an authorized service center/department.

Depress clutch/brake pedal.

Disengage attachment clutch.

Recharge or replace battery.

Replace fuse.

Clean battery terminals.

Check all wiring.

Check/replace ignition switch.

Check/replace solenoid or starter.

Contact an authorized service center/department.

Recharge or replace battery.

Clean battery terminals.

Check all wiring.

Check/replace solenoid or starter.

28

Image 28
Contents RRIIFTSMAN Sears Craftsman Help LineLimitedtwoyearwarrantyoncraftsmanridingequipmentparts Limited 90 DAY Warranty on BatteryGeneral Operation Slope OperationDo not ChildrenService Mower blades are sharp and can cut3ROUND Product SpecificationsRepair Agreement Steering Wheel Keys Video Cassette Slope SheetHOW to SET UP Your Tractor To Remove Tractor from CartonBefore Rolling Tractor OFF Skid Unpack CartonTo Drive Tractor OFF Skid Install SeatSee Operation section for location Function of controls Install Mulcher Plate Check for Proper Position of ALL BeltsH L Knowyour Tractor HOW to USE Your Tractor StoppingTo Operate on Hills To Adjust Gauge WheelsTo Operate Mower Towing Carts and Other Attachments Before Starting the EngineAddgasoline Check Engine OIL LevelMowing Tips Mulching Mowing TipsLubrication Chart General RecommendationsBefore Each USE ZerkZerkBrake Operation TiresOperator Presence System Blade CareClean AIR Screen Clean AIR INTAKE/COOLING AreasTransaxle Cooling BeltsSparkplugs IN-LINE Fuel FilterMuffler AIR FilterCleaning To Install MowerTractor To Remove MowerTo Level Mower Housing SIDE-TO-SIDE AdjustmentTo Adjust Brake Belt InstallationTo Replace Motion Drive Belt Belt RemovalTo Adjust Steering Wheel Alignment To Start Engine with a Weak BatteryTransaxlegearshiftlever Front Wheel TOE-IN/CAMBERTo Remove Hoodand Grill Assembly Replacing BatteryTo Replace Headlight Bulb Interlocks and RelaysTo Adjust Throttle Control To Adjust CarburetorEngine CableAcceleration Test Battery TractorEngine Fuel System Drain oil with engine warm and replaCorrection Troubleshooting Chart ProblemCause Troubleshooting Chart Problemcause CorrectionTroubleshooting Chart Problem Cause87A Tractor - Model Number SchematicFss Tractor - Model Number Electrical Tractor - Model Number Electrical 163465146147 166180 Fuse 15AMP 27 73510400 Nut Keps Hex 1/4-20UricTractor - Model Number 917.271051 Chassis and Enclosures Tractor - Model Number Chassis and Enclosures KEY Part DescriptionTractor - Model Number Ground Drive 106933X 166231130804 Rod, Brake 150360 Nut, Nylock STD541237 158391X428 Bolt 145Tractor - Model Number 917.271051 Steering Assembly Tractor - Model Number Steering Assembly KEY Part NO. NO.DESCRIPTIONTractor - Model Number Engine 40tOptional Equipment Spark Arrester162156 17720410Tractor - Model Number Seat Assembly Tractor --MODEL Number Decals Wheels & TiresTractor - Model Number Lift Assembly KEY Part NO. NO,DESCRIPTION Shaft Asm. Lift 105767X PinGrooveA/,J Tractor --MODEL Number Mower DeckTractor - Model Number Mower Deck KEY Part NO. noPage Ring Gear Part DescriptionGiven in U.S Crankshaft Fuel System Cylinder HEAD, Valve and Breather Io3 Blower Housing and Baffles KEY Part Description AIR Intake KEY Part DescriptionCrankshaft KEY Part Description Engine Controls KEY Part NO. NO,DESCRIPTIONFlange M6xl.0 12-041-0t-S12-757-03-S 24-186-03-SIgnition ! Electrical Crankcase KEY Part Description OIL PAN / Lubrication KEY Part DescriptionKEY Part NO. no Starting System KEY Part NO. NO,DESCRIPTIONPage Page Page Only Ride UP and Down Hill Not Across HillSighting AWL8004694663 SU-HOGAR