Sears 917.25049 owner manual Troubleshooti Points, Problem Cause Correction

Page 29

IjILj

I I'l i i,l,,

TROUBLESHOOTI POINTS

PROBLEM

CAUSE

CORRECTION

Will not start

Hard to start

1 Out of fue!,

2.Engine not "CHOKED" properly, 3_ Engine flooded.

4.Bad spark plug. 5, Dirty air filter.

6, Dirty fuel filter,

7Water in fuel.

8, Loose or damaged wiring.,

9Carburetor out of adjus_'nent 10,, Engine valves out of adjustment.,

t_ Dirty air filter

2.Bad spark plug.

3, Weak or dead battery., 4_ Dirty fuel filter,

5, Stale or dfrty fueL

6Loose or damaged widng, 7, Carburetor out of adjustment

8.Engine valves out of adjustment.

1Fill fuel tank,

2See "TO START ENGINE _ in Operation section., 3, Wait several minutes before attempting to start 4, Replace spark plug.

5,, Clean/replace air filter, 6, Replace fuel filter,

7,, Drain fuel tank and carburetor, refilf tank with fresh gasoline and replace fuel filter,

8, Check all wiring,

9, Contact an authorized service centerldepartment

10_ Contact an authorized servtce center/department

1, Clean/replace air filter 2, Replace spark plug,,

3_ Recharge or replace battery 4, Replace fuel filter.

5.Drain fuel tank and refill with fresh gasoline,, 6., Check all wiring,

7_ Contact an authorized service centerldepartrnent,

8Contact an authorized service center/department

Engine will not turn over

1°

Clutch!brake pedal not depressed,

 

2.

Attachment clutch Is engaged.

 

3.

Weak

or dead battery,

 

4,,

Blown

fuse_

 

 

5,

Corroded battery terminals,

 

6.

Loose

or damaged wiring

 

7.

Faulty

Ignition switch,

 

8

Faulty

solenoid

or starter,

 

9.

Faulty

operator

presence switch(es)

i

t, Depress clutch/brake pedal,

2, Disengage attachment clutch_ 3o Recharge or replace battery

4., Replace fuse,

5.Clean battery terminals,, 6., Check all wiring

7,

Check/replace

ignition

switch,

8

Check/replace

solenoid

or starter,

9,

Contact an authorized

service centertdepartment,

Engine clicks but wilt not start

Excessive vibration

!.Weak or dead battery°

2.Corroded battery terminals.,

3Loose or damaged wiring,, 4, Faulty solenoid or starter,

1Cutting too much grass/too fast,,

2 Throttle in "CHOKE" position.

3, Build-up of grass, leaves and trash under mower.

4.Didy air filter.

5.Low otl leveltdirty oil,

6.Faulty spark plug

7, Dirty fuel filter.

8Stale or dirty fuel 9- Water tn fuel

10.Spark plug wire loose.

11..Dirty engine air screen/fins, 12, Dirtylcfogged muffler,,

13, Loose or damaged wiring

14.Carburetor out of adjustment. 15, Engine valves out of adjustment,

1, Wom, bent or loose blade. 2, Bent blade mandrel,

3.Loosefdamaged part(s),,

1Recharge or replace battery, 2, Clean battery terminals,

3.Check all wiring

4,, Check/replace solenoid or starter

1, Set in "Higher Cut" position/reduce speed,

2.Adjust throttle control

3.Clean underside of mower housing, 4, Clean/replace afr filter,

5.Check ofl leveltchange oit,

6.Clean and regap or change spark plug

7.Replace fuel filter,

8, Drain fuel tank end refill with fresh gasoline,

9, Drain fuel tank and carburetor, refill tank with fresh gasoIine and replace fuel filter,,

t0, Connect and tighten spark plug wire, 11_, Clean engine air screen/fins

12, Clean/replace muffler, _3. Check all wiring_

14, Contact an authorized service centertdepartmenL 15r Contact an authorized service center/dspartment_

!, Replace blade, Tighten blade bolt, 2 Replace blade mandrel

3.Tighten bose part(s), Replace damaged parts

29

Page 28 Page 30
Image 29
Page 28 Page 30
Contents Model Slope Operation Safe Operation Practices for Ride-On MowersProduct Specifications Maintenance AgreementLimited TWO Year Warranty on Craftsman Riding Equipment Limited 90 DAY Warranty on BatteryFable of Contents Performance ACCESSORME$ a Attach EntsEngine Maintenance Contents of Hardware Pack Before Rolling Tractor OFF Skid Tools Requdred for AssemblyAttach Steering Wheel See Fig To Roll Tractor OFF Skid See FigConnect Battery See Fig HOW to SET UP Your TractorInstall Seat See Fig Check Tire PressureCheck for Proper Position of ALL Belts Check Deck LevelnessChecklist Lock OPERATmONKnow Your Tractor To Adjust Mower Cutting Height See Fig HOW to USE Your TractorTo SET Parking Brake See Fig Stopping See FigTo Operate on Hills To Adjust Gauge Wheels See FigTo Operate Mower See Figs To Transport See FigsCheck Engine OIL Level See Fig Before Starting the EngineADD Gasoline To Start Engine See FigFreewheel lever while the engine is run Mowing TipsPurge Transmission Maintenance Schedule Before Each USE Lubrication ChartCusto General RecommendationsBrake Operation Tractor To Sharpen BladeTires Blade CareEngine Clean AIR Screen See FigTransaxle Cooling Transaxle Pump FluidNsibilities CustomerEngine OIL Filter Spark PlugsTo Level Mower Housing To Install MowerHeight about 3/16 Recheck measurements After adjusting To Remove Mower See FigTo Replace Mower Drive Belt Service and AdjustmentsMower Drive Belt Removal See Fig22 Both Front Links should be Equal in LengthTo Replace Mower Blade Drive Belt See Fig To Adjust Brake See FigTo Adjust Attachment Clutch See Fig To Adjust Motion Control LeverTo Adjust Steering Wheel Alignment Front Wheel TOE-IN Adjustment Ervjce AN AdjustmentsTo Start Engine with a Weak Battery Front Wheel CamberTo Remove Hood and Grill Assembly To Adjust Attachment Lift SpringTo Replace Headlight Bulb Interlocks and RelaysTo Adjust Carburetor See Fig To Adjust Throttle Control Cable See Figs, 34Preliminary Setting Final SettingTractor BatteryOther Fuel SystemTroubleshooti Points Problem Cause CorrectionProblemcause Troubleshooting PointsClips Were Removed for Properly Secure Your WiringServicing of UNIT, They Should be Replaced toElectrical Repair Parts43 145673 Solenoid KEY Part Description471205 17/ 41 102 Chassis and Enclosures74760616 14473773680600 142992MODLNUMBIS17.2SO4so 7070E Key 1/4 x 7563R Washer Thrust Axle Harden Ground DriveCap Plunger 73800500Steering Assembly 73901000 Repair Parts\ \ Engine Tractor - Model NumberMower Deck Nut, Fig Top Lock Cntr 9/t6 KEY Part NO. noSeat Assembly Decals Tube, Front Service Item OnlyWheels & Tires 245 111212\ 2O 19 Lift AssemblySpring Assist 73350800Rod, Adj Lift Tractor -- Model Number KEY Part NO. no Description Hydro Gear Transaxle - Model Number142878 142927Hydro Gear Pump Model Number BU-10L-118 Tractor --MODEL NumberVENT Kohler ENGINE- Model Number MV18S, Type NumberBreatherand AIR Intake KEY Part Description Kohler Engine Model Number MV18S, Type NumberBaffles & Shroud KEY Part Description Breather & Vent KEY Part DescriptionP14 Not Illustrated Crankcase Carburetor KEY Part NO. no Descripon DescriptionU Ti Electric Starter KEY Part Description KEY Part NO. no CrankshaftDipstick KEY Part Description Not Illustrated -.25 450 Exhaust KEY Part+LYWHEEtI Governor KEY Part Flywheel KEY Part NO. no52 078 Fuel Pump KEY Partdescription No noOIL Filter Piston ROD OIL Switch J Camshaft and ValvesOIL PAN KEY Part LOW OIL Pressure SwitchOIL Filter KEY Part NO. no Piston & ROD KEY Part NO. noServ Notes Page Sight and Hold this Level with Only Ride UP and Down Hill Not Across HillSKY Line or Tree 15 MAXOwners Manual If YOU Need Repair Service Or Parts800473-7247 Model Number Engine Model NO. MV18S-58560

917.25049 specifications

The Sears 917.25049 is a notable lawn tractor that has garnered attention for its reliability and performance in residential lawn care. Designed primarily for homeowners who require an efficient means of maintaining their lawns, this model combines user-friendly features with robust technology to deliver an exceptional mowing experience.

At the heart of the Sears 917.25049 is its powerful engine, typically a 17.5-horsepower Briggs & Stratton overhead valve engine. This engine is known for its durability and efficiency, enabling the tractor to handle various terrains with ease. The consistent power output allows for optimal performance, making it suitable for mowing various grass types and tackling uneven landscapes.

One of the standout features of the Sears 917.25049 is its 42-inch cutting deck. This is an ideal size for residential properties, striking a balance between maneuverability and cutting efficiency. The deck design allows for side discharging, bagging, or mulching, providing users with multiple options for handling grass clippings based on their preferences and lawn care strategies.

The mower deck is equipped with adjustable cutting heights, offering several options between one and four inches. This adaptability enables homeowners to customize their mowing height based on seasonal needs, ensuring a healthy lawn throughout the year. The easy-to-use lever for adjusting the cutting height makes this process quick and convenient.

In terms of technology, the Sears 917.25049 features a hydrostatic transmission system. This technology allows for smooth acceleration and provides seamless changes in speed without the need for clutching. Users can enjoy a more intuitive driving experience, particularly when navigating tight spaces or turning corners.

The tractor also has a comfortable operator station, equipped with a spacious and well-padded seat that ensures comfort during extended mowing sessions. The steering system is designed for ease of handling, allowing for quick and responsive turning capabilities. Safety features include an operator presence control, which ensures the mower engine shuts off if the operator leaves the seat unexpectedly.

In conclusion, the Sears 917.25049 lawn tractor is an excellent choice for homeowners seeking a robust and reliable machine for lawn care. With its powerful engine, versatile cutting deck, user-friendly design, and advanced technologies, it stands out as a dependable tool for maintaining a beautiful lawn throughout the seasons.
Top Page Image Contents