Multiquip DCA-150SSJU3 Installation, Outdoor Installation, Indoor Installation, Mounting

Page 17

Outdoor Installation

Install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around. Also install the generator in a manner so that the exhaust will not be discharged in the direction of nearby homes.

The installation site must be relatively free from moisture and dust. All electrical equipment should be protected from excessive moisture. Failure to do will result in deterioration of the insulation and will result in short circuits and grounding.

Foreign materials such as dust, sand, lint and abrasive materials have a tendency to cause excessive wear to engine and alternator parts.

CAUTION - EXHAUST HAZARD

Pay close attention to ventilation when operating the generator inside tunnels and caves. The engine exhaust contains noxious elements. Engine exhaust must be routed to a ventilated area.

Indoor Installation

Exhaust gases from diesel engines are extremely poisonous. Whenever an engine is installed indoors the exhaust fumes must be vented to the outside.The engine should be installed at least two feet from any outside wall. Using an exhaust pipe which is too long or too small can cause excessive back pressure which will cause the engine to heat excessively and possibly burn the valves.

Mounting

The generator must be mounted on a solid foundation (such as concrete) and set firmly on the foundation to isolate vibration of the generator when it is running. The generator must set at least 6 inches above the floor or grade level (in accordance to NFPA 110, Chapter 5-4.1). DO NOT remove the metal skids on the bottom of the generator. They are to resist damage to the bottom of the generator and to maintain alignment.

DCA-150SSJU3 — INSTALLATION

Generator Grounding

To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground.

Article 250 (Grounding) of the National Electrical Code (NEC) provides guide lines for proper grounding and specifies that the cable ground shall be connected to the grounding system of the building as close to the point of cable entry as practical.

NEC articles 250-64(b) and 250-66 set the following grounding requirements:

1.Use one of the following wire types to connect the generator to earth ground.

a.Copper - 10 AWG (5.3 mm2) or larger.

b.Aluminum - 8 AWG (8.4 mm2) or larger.

2.When grounding the generator (Figure 4) connect the ground cable between the lock washer and the nut on the generator and tighten the nut fully. Connect the other end of the ground cable to earth ground.

3.NEC article 250-52(c) specifies that the earth ground rod should be buried aminimum of 8 ft. into the ground.

When connecting the generator

NOTEto any buildings electrical system ALWAYS consult with a licensed electrician.

DCA-150SSJU3— OPERATION AND PARTS MANUAL — REV. #0 (11/14/07) — PAGE 17

Image 17
Contents Model DCA-150SSJU3 Parts List NO. M38703011042 DCA-150SSJU3- Operation and Parts Manual REV. #0 11/14/07 Wilmington Ave Carson, CA Heres HOW to GET HelpTable of Contents When ordering parts Please supply the following information Parts Ordering ProceduresDCA-150SSJU3 Specifications Dimensions DCA-150SSJU3 Dimensions TOP, Side and FrontHazard Symbols DCA-150SSJU3 Safety Message Alert SymbolsThis generator, other property, or DCA-150SSJU3 Safety Message Alert SymbolsDCA-150SSJU3 Rules for Safe Operation General SafetyGenerator Grounding Electrical SafetyDCA-150SSJU3 Rules for Safe Operation Battery Safety Maintenance SafetyEmergencies Towing &Transporting SafetyDCA-150SSJU3 Generator Decals Generator Decals Cont inued DCA-150SSJU3 Generator DecalsTypical Generator Grounding Application DCA-150SSJU3 InstallationOutdoor Installation DCA-150SSJU3 InstallationIndoor Installation When connecting the generatorEngine Operating Panel GeneratorGenerator Control Panel Output Terminal PanelMajor Components DCA-150SSJU3 Major ComponentsDisplay Parameters Menu Button Press this button to enter or exit menu screensFirst Time Start Up DCA-150SSJU3 Diagnostic DisplayMain Menu Navigation Selecting a LanguageStored Fault Codes Diagnostic CodeEngine Configuration Data To make a selectionDCA-150SSJU3 Diagnostic Display 24 DCA-150SSJU3- Operation and Parts Manual REV. #0 11/14/07 Display will return to the single or four parameter screen Auxiliary Gage FaultActive Fault Codes Shut Down Codes Backlight AdjustmentCode from an engine control unit the single or four DamageIs highlighted Contrast AdjustmentIntensity Select Units Setup 1- Up DisplayUp display function Once the Setup 1-up Display menu icon has beenSetup menu Automatic Scan on Select the 4-Up Custom Setup from the 4-Up Setup menu Setup 4-Up DisplayUtilities information and troubleshooting Gage Data is selected the PowerView will When the gage data has cleared, the displayVersion currently in the diagnostic display Half duplexTouch the Menu Button Highlight it, then touch Enter Touch the Menu button again to return to the MainMenu Glossary Troubleshooting information DCA-150SSJU3 Diagnostic DisplayECU did not respond to the PowerView request No parameter selected for this 4- UP quadrantDCA-150SSJU3 Generator Control Panel Fuel Gauge Indicates amount of diesel fuel available DCA-150SSJU3 Engine Operating PanelAuto On/Off Engine Controller Mpec DCA-150SSJU3 Engine Operating PanelOutput Terminal Familiarization DCA-150SSJU3 Output Terminal Panel Familiarization120VAC Gfci Receptacles DCA-150SSJU3 Output Terminal Panel FamiliarizationOver Current Relay Connecting LoadsThree Phase Load Single Phase LoadDCA-150SSJU3 Load Application Motors and motor-drivenVoltage Change-Over Board Generator OutputVoltagesGenerator Amperage 120V 240VChange-Over Switch How to Read the Output Terminal GaugeDCA-150SSJU3 Generator OUTPUTS/ Gauge Reading Maximum AmpsDCA-150SSJU3 Output Terminal Panel Connections Three-Phase PositionUvwo Terminal Output Voltages 3Ø 240/139 Output Terminal Lug Voltages1Ø 240V/120V Output Terminal Lug Voltages DCA-150SSJU3 Output Terminal Panel Connections3Ø 480/277 Output Terminal Lug Voltages Circuit Breakers DCA-150SSJU3 SetupLubrication Oil Fuel CheckRefueling Refueling ProcedureAir Cleaner Fan Belt Tension Cleaning the RadiatorCoolant Antifreeze Operation FreezingWeatherBattery Cable Installation BatteryWiring AlternatorPlace the engine speed switch in the LOW down position DCA-150SSJU3 Generator START-UP Procedure ManualBefore Starting Engines exhaust contains harmful emissionsEngine Speed Switch High When the generator is set Auto mode, the generator will Starting Auto ModeNo Load Tachometer GaugePlace the Mpec Control Switch in the Auto position Place the engine speed switch in the High positionEmergency Shutdown Procedure DCA-150SSJU3 Generator SHUT-DOWN ProceduresNormal Shutdown Procedure DCA-150SSJU3 Maintenance Engine Air Removal Cleaning the Fuel StrainerCheck Oil Level Replacing Oil FilterTo ensure adequate starting DCA-150SSJU3 Maintenance HEATER/CHARGERTrailer Maintenance DCA-150SSJU3 Maintenance TrailerBrake Adjustment DCA-150SSJU3 Maintenance TrailerBrakes Check the wheel and drum for free rotationSuspension Tires/Wheels/Lug NutsTireWear/Inflation Start all wheel lug nuts by hand DCA-150SSJU3 Maintenance TrailerLug Nut Torque Requirements DCA-150SSJU3 -TRAILERWIRING Diagram Generator Wiring Diagram DCA-150SSJU3 Generatorwiring DiagramDCA-150SSJU3 Enginewiring Diagram Generator Troubleshooting DCA-150SSJU3 -TROUBLESHOOTING GeneratorEngine Controller Troubleshooting Mpec DCA-150SSJU3 -TROUBLESHOOTING Engine ControllerDCA-150SSJU3- Operation and Parts Manual REV. #0 11/14/07 DCA-150SSJU3 Explanation of Code in Remarks Column Sample Parts ListDCA-150SSJU3 Suggested Spare Parts Part number on this Suggested Spare Parts listDCA-150SSJU3 Generator Assy Includes Item W C01100001128131070013 8131611014DCA-150SSJU3- Control BOX Assy 0330000210 M32130016020330000240 0330000180DCA-150SSJU3- Control BOX ASSY. M3213601904 M3270100304M3213602004 37A 0330000275DCA-150SSJU3- Engine and Radiator Assy R521052 M3923200084RE504836 RE529643DCA-150SSJU3- Engine and Radiator ASSY. 0603300285 06033065900605511395 0603306395Output Terminal Assy DCA-150SSJU3- Outputterminal AssyM9220100304 M3230700003M9220100404 0039316000DCA-150SSJU3- Battery Assy M9310500404 0602220196M9103000504 0602220921DCA-150SSJU3- Muffler Assy 0016910025 M3330100502M3333001303 M3333200104DCA-150SSJU3- Fueltank Assy 0605505070 M33630019020605501076 0605516090Enclosure Assy DCA-150SSJU3- Enclosure AssyM1413400004 M3413002302M3423002502 M3493111903Enclosure ASSY. DCA-150SSJU3- Enclosure ASSY.M9113000002 33A 00412060000021806016 35A 003000600094 DCA-150SSJU3- Operation and Parts Manual REV. #0 11/14/07 M9110100304 63A M911610000464A M9116100004 0601850097DCA-150SSJU3- Rubber Seals Assy 0228901005 02292012000228901090 0228901150DCA-150SSJU3- Nameplate and Decals Assy M9520100304 M3550003003M9520100603 M3550002803DCA-150SSJU3- Nameplate and Decals ASSY. 0600500090 M95102000020021106016 M3560100903Payment Terms DCA-150SSJU3- Operation and Parts Manual REV. #0 11/14/07 Your Local Dealer is

DCA-150SSJU3 specifications

The Multiquip DCA-150SSJU3 is a powerful, reliable diesel generator that is designed to meet the demanding energy needs of various applications, including construction sites, events, and emergency power supply. With its robust construction and advanced technology, the DCA-150SSJU3 stands out in the competitive market of portable generators.

One of the main features of the DCA-150SSJU3 is its impressive output capabilities. This generator generates a continuous output of 150 kVA, which is more than enough to power multiple tools and equipment simultaneously. It is equipped with a high-quality, efficient diesel engine that not only delivers ample power but also ensures fuel efficiency, reducing operational costs over time.

The design of the DCA-150SSJU3 prioritizes user convenience and operational efficiency. It is fitted with a digital control panel that provides real-time monitoring of critical parameters such as voltage, frequency, and operating hours. This user-friendly interface simplifies the process of managing power output and helps operators maintain optimal performance.

Moreover, the DCA-150SSJU3 is equipped with advanced soundproofing technology, making it one of the quieter models in its class. This feature is particularly beneficial in environments where noise regulations must be adhered to, such as residential areas or during nighttime operations.

Durability is another key characteristic of the Multiquip DCA-150SSJU3. The generator is housed in a robust steel enclosure that protects it from external elements, ensuring longevity and reliable performance even in challenging conditions. Additionally, the generator has been designed with easy service access in mind, facilitating maintenance procedures and minimizing downtime.

Safety is paramount in generator design, and the DCA-150SSJU3 does not fall short in this aspect. It is equipped with a comprehensive range of safety features, including low oil shut-off, overload protection, and emergency stop buttons, ensuring safe operation for users.

In conclusion, the Multiquip DCA-150SSJU3 is a versatile and resilient diesel generator that excels in performance, efficiency, and safety. With its powerful output, advanced technologies, and user-friendly design, it is an ideal choice for those needing reliable power solutions across various demanding environments. Whether for temporary applications or as an emergency backup, the DCA-150SSJU3 is a generator that offers peace of mind and dependable performance.