Exmark Frontrunner manual

Page 15

1.6.3When new components are installed, be sure that current safety signs are affixed to the replaced components.

1.6.4New safety signs may be obtained from Exmark Mfg. Co. Inc.

1.6.5Safety signs may be affixed by peeling off the backing to expose the adhesive surface. Apply only to a clean, dry surface. Smooth to remove any air bubbles.

1.6.6Familiarize yourself with the following safety signs and instruction labels. They are critical to the safe operation of your Exmark commercial mower.

PART NO. 1-513746

PART NO. 1-513747

LOCATION: Outside of Rear

LOCATION: LH Side of Battery Holder

Muffler Guard

 

PART NO. 1-643339

PART NO. 1-523552LOCATION: On Top of Radiator

LOCATION: Top Surface of

Hydraulic Tank

PART NO. 103-1636

PART NO. 109-2358

LOCATION: On Top of

 

 

 

 

 

 

Fuel Tank

LOCATION: On Control

 

 

 

 

 

 

 

 

 

 

 

 

 

Panel

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

PART NO. 103-0233

LOCATION: On Front of the

Fan Shroud

PART NO. 109-2356

LOCATION: Top of

Console,

RH Side

PART NO. 103-5881

PART NO. 103-7218

LOCATION: On top of Radiator

LOCATION: On Seat Support Plate

PART NO. 98-5954

PART NO. 93-4361

 

LOCATION: Top of Radiator

LOCATION: On LH and RH Side,

PART NO. 103-2076

 

Near Back of Unit

 

LOCATION: On Top of

 

 

 

 

Radiator

10

Image 15
Contents Model No Serial No Potential Hazard Exmark Parts PLUS→ Program Operators Manual Table of Contents Training SafetyYour Safety is Involved Safety Alert SymbolCarbon monoxide can kill you Diesel fuel is flammable Operation When feasible, avoid operating the equipment in wet grass There is no rollover protection when the roll bar is down Page Maintenance and Storage Safety Signs Page Page Specifications Dimensions Hydrostatic Ground Drive SystemTires Operation Instructions Torque RequirementsControls Glow Plug Chart Page Operating Instructions PRE-STARTRotating blades under the mower deck are dangerous Transporting Tip-over of the unit could cause serious injury or death Maintenance & Adjustments Periodic MaintenanceService Interval Daily Service Interval Monthly Service Interval Daily or more often in dry conditions Service Interval Daily Check starting circuitCheck the kill circuits PTO must not engage Check the PTO circuitService air cleaner Potential Hazard Service Interval 40 hr Service Interval 40 hrsDo not overtighten Service Interval Once Yearly Service Interval Refer to chartService Interval 160 hrs Service Interval 400 hrs. or as required Service Interval YearlyFirst Interval 250 hrs Normal Interval Yearly Spring Tensioned No adjustment necessary AdjustmentsPage Potential Hazard Set neutral Page Weight transfer springs may have stored energy Battery Disposal Waste DisposalMotor OIL Disposal Engine will not Start Trouble ShootingMower Pulls Left or Right W/LEVERS Fully Forward Mower Cuts UnevenlyEngine Warning Systems Troubleshooting TableElectrical Diagram Hydraulic Diagram Year Limited Warranty Exmark Turf Equipment Page Page Page See EXMARK’S Complete Line of Accessories