Husqvarna 5525PW warranty Troubleshooting Points, Problem Cause Correction

Page 18

TROUBLESHOOTING POINTS

PROBLEM

 

CAUSE

 

CORRECTION

 

 

 

 

 

Does not start

1.

Dirty air filter.

1.

Clean/replace air filter.

 

2.

Out of fuel.

2.

Fill fuel tank.

 

3.

Stale fuel.

3.

Empty fuel tank and refill tank with fresh,

 

 

 

 

clean gasoline.

 

4.

Water in fuel.

4.

Empty fuel tank and refill tank with fresh,

 

 

 

 

clean gasoline.

 

5.

Spark plug wire is disconnected.

5.

Connect wire to plug.

 

6.

Bad spark plug.

6.

Replace spark plug.

 

7.

Loose blade or broken blade adapter.

7.

Tighten blade bolt or replace blade adapter.

 

8.

Control bar in released position.

8.

Depress control bar to handle.

 

9.

Control bar defective.

9.

Replace control bar.

 

10.

Fuel valve lever (if equipped) in OFF position.

10.

Turn fuel valve lever to the ON position.

 

11.

Weak battery (if equipped).

11.

Charge battery.

 

12.

Disconnected battery connector (if equipped).

12.

Connect battery to engine.

 

 

 

 

 

Loss of power

1.

Rear of lawn mower housing or cutting

1.

Raise cutting height.

 

 

blade dragging in heavy grass.

 

 

 

2.

Cutting too much grass.

2.

Raise cutting height.

 

3.

Dirty air filter.

3.

Clean/replace air filter.

 

4.

Buildup of grass, leaves and trash under

4.

Clean underside of mower housing.

 

 

mower.

 

 

 

5.

Too much oil in engine.

5.

Check oil level.

 

6.

Walking speed too fast.

6.

Cut at slower walking speed.

 

 

 

 

 

Poor cut –

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

uneven

2.

Wheel heights uneven.

2.

Set all wheels at same height.

 

3.

Buildup of grass, leaves and trash under

3.

Clean underside of mower housing.

 

 

mower.

 

 

 

 

 

 

 

Excessive

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

vibration

2.

Bent engine crankshaft.

2.

Contact a qualified service center.

 

 

 

 

 

Starter rope

1.

Engine flywheel brake is on when control

1.

Depress control bar to upper handle before

hard to pull

 

bar is released.

 

pulling starter rope.

 

2.

Bent engine crankshaft.

2.

Contact a qualified service center.

 

3.

Blade adapter broken.

3.

Replace blade adapter.

 

4.

Blade dragging in grass.

4.

Move lawn mower to cut grass or other

 

 

 

 

hard surface before starting.

 

 

 

 

 

Grass catcher

1.

Cutting height too low.

1.

Raise cutting height.

not filling

2.

Lift on blade worn off.

2.

Replace blade.

(if so equipped)

3.

Catcher not venting air.

3.

Clean grass catcher.

 

 

 

 

 

Hard to push

1.

Grass is too high or wheel height is too low.

1.

Raise cutting height.

 

2.

Rear of lawn mower housing or cutting

2.

Raise rear of lawn mower housing one (1)

 

 

blade dragging in heavy grass.

 

setting higher.

 

3.

Grass catcher too full.

3.

Empty grass catcher.

 

4.

Handle height position not right for you.

4.

Adjust handle height to suit.

 

 

 

 

 

Loss of drive

1.

Belt wear.

1.

Check/replace drive belt.

(or slowing of

2.

Belt off of pulley.

2.

Check/reinstall drive belt.

drive speed)

3.

Drive cable worn or broken.

3.

Put belt on pulleys / replace belts if broken.

 

4.

“Loose” drive control system.

4.

Adjust drive control.

 

 

 

 

 

18

Page 17 Page 19
Image 18
Page 17 Page 19
Contents Operator’s Manual Manual de Operario Safety Rules ChildrenII. General Operation Table of Contents HOW to SET UP Your Lawn Mower AssemblyProduct Specifications Customer ResponsibilitiesTo Assemble Grass Catcher See Fig Install Starter Rope See FigTo Install Attachments Tighten T-knobMeets Cpsc Safety Requirements OperationKnow Your Lawn Mower HOW to USE Your Lawn Mower Engine SpeedEngine Zone Control To Empty Grass Catcher See Fig Before Starting EngineTo Convert Mower ADD OIL See FigMowing Tips To Stop EngineTo Start Engine Mulching Mowing TipsGeneral Recommendations MaintenanceLubrication Chart Before Each USEDrive Wheels Lawn MowerTires Blade CareGear Cases EngineGrass Catcher To Change Engine OIL See FigIN-LINE Fuel Filter See Fig CleaningWater Washout Feature See Fig MufflerRear Deflector Service and AdjustmentsTo Adjust Cutting Height To Remove Drive Belt See FigsTo Replace Drive Belt See Figs FrontCarburetor To Adjust Handle See FigStorage Handle See FigsEngine OIL OtherFuel System CylinderTroubleshooting Points Problem Cause CorrectionConsumer Wheeled Products Limited Warranty HOW to Obtain Service Consumer Wheeled Limited Warranty Chart Consumer Wheeled Limited Warranty Chart Reglas DE Seguridad NiñosII. Operacion IV. Manejo Seguro DE Gasolina Tabla DE MateriasIII. Operacion Sobre LAS Cuestas ServicioResponsabilidades DEL Cliente Montaje / PRE-OPERACIÓNEspecificaciones DEL Producto Como Preparar SU SegadoraPara Montar EL Recogedor DE Césped Vea Fig Instalación DEL Cordón Arrancador Vea FigPara Instalar LOS Accesorios Operación Familiarícese CON SU SegadoraCumple CON LOS Requisitos DE Seguridad DE LA Cpsc Como Usar SU Segadora Velocidad DEL MotorControl DE Zona DEL Motor Para Vaciar EL Recogedor DE Césped Vea Fig Para Convertir LA SegadoraAntes DE Hacer Arrancar EL Motor Agregue Aceite Vea FigConsejos Para Segar Y Acolchar Para Parar EL MotorPara Hacer Arrancar EL Motor Consejos Para SegarAntes DE Cada USO MantenimientoRecomendaciones Generales LubricaciónRuedas DE Impulsión SegadoraLlantas Cuidado DE LA CuchillaCajas DE Engranajes MotorRecogedor DE Césped Para Cambiar EL Aceite DEL Motor Vea FigSilenciador LimpiezaFiltro DE Combustible Vea Fig BujíaDesviador Trasero Servicio Y AjustesPara Ajustar LA Altura DE Corte Para Remover Correa DE Impulsión Vea Figs yPara Cambiar Correa DE Impulsión Vea Figs y FrenteCarburador AlmacenamientoPara Ajustar EL Mango Vea Fig Mango Vea Figs yAceite DEL Motor OtrosSistema DE Combustible CilindroSolución DE Problemas Problema Causa CorrecciónProductos con ruedas para consumidor Garantía limitada Cómo Obtener Servicio 575 49 43-01 W 2012 IR Consumidor Comercial Alquiler 03/03/2014 by
Related manuals
Manual 30 pages 21.92 Kb

5525PW specifications

Husqvarna, a renowned name in outdoor power equipment, offers an array of high-performance chainsaws, including the 6026PW, 9030PW, 1335PW, and 5525PW models. Each model is designed to cater to various cutting needs, making them suitable for both professional and amateur users.

The Husqvarna 6026PW boasts a robust engine, specifically designed for heavy-duty use. With its powerful air-cooled two-stroke engine, this model delivers exceptional cutting performance while maintaining low levels of vibration, which reduces user fatigue during extended use. The integrated air filter system prolongs the lifespan of the engine, ensuring it operates efficiently under demanding conditions.

The 9030PW model stands out for its advanced technology and ease of use. It features an automatic oiler system that ensures consistent lubrication of the chain, enhancing both performance and longevity. The 9030PW also benefits from an ergonomic design, which includes an adjustable handle for optimal comfort and control. This model's lightweight construction makes it easy to maneuver, perfect for detailed trimming or larger cutting tasks.

The Husqvarna 1335PW is designed with the homeowner in mind, offering a perfect balance of power and finesse. One of its defining features is the X-Torq engine, which provides higher torque over a wider RPM range while also reducing fuel consumption and emissions. The 1335PW also includes a quick-release air filter for easy cleaning and maintenance, ensuring your chainsaw remains in peak condition.

Finally, the Husqvarna 5525PW combines strength and versatility, making it suitable for a diverse range of cutting applications. This model features a durable chain brake for added safety, helping to prevent accidents during operation. The 5525PW's easy-to-start system minimizes starting effort, allowing users to get to work quickly without hassle.

All four models benefit from Husqvarna's commitment to user safety and comfort, making them ideal for both professionals and DIY enthusiasts. With innovative features and robust design, the Husqvarna 6026PW, 9030PW, 1335PW, and 5525PW represent the perfect blend of performance, durability, and technology, carving out a niche for themselves in the competitive chainsaw market.
Top Page Image Contents