Husqvarna YT180 owner manual Tractor, Brake Operation, Tires, Blade Care

Page 15

CUSTOMER RESPONSIBILITIES

TRACTOR

Always observe safety rules when performing any mainte- nance.

BRAKE OPERATION

If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjust- ments section of this manual).

TIRES

•Maintain proper air pressure in all tires (See "PROD- UCT SPECIFICATIONS" on page 3 of this manual).

•Keep tires free of gasoline, oil, or insect control chemi- cals which can harm rubber.

•Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.

BLADE CARE

For best results mower blades must be kept sharp. Re- place bent or damaged blades.

•Slide blade on to an unthreaded portion of the steel bolt or pin and hold the bolt or pin parallel with the ground. If blade is balanced, it should remain in a horizontal position. If either end of the blade moves downward, sharpen the heavy end until the blade is balanced.

NOTE: Do not use a nail for balancing blade. The lobes of the center hole may appear to be centered, but are not.

CENTER HOLE

BLADE

5/8" BOLT OR PIN

FIG. 14

BLADE REMOVAL (See Fig. 13)

•Raise mower to highest position to allow access to blades.

•Remove hex bolt, lock washer and flat washer securing blade.

•Install new or resharpened blade with trailing edge up towards deck as shown.

•Reassemble hex bolt, lock washer and flat washer in exact order as shown.

•Tighten bolt securely (30-35 Ft. Lbs. torque).

IMPORTANT: BLADE BOLT IS GRADE 8 HEAT TREATED.

NOTE: Do not use a nail for balancing blade. The lobes of the center hole may appear to be centered, but are not.

BLADE

MANDREL

ASSEMBLY

 

 

TRAILING EDGE

FLAT WASHER

LOCK WASHER

HEX BOLT (GRADE 8)*

*A GRADE 8 HEAT TREATED BOLT CAN BE

IDENTIFIED BY SIX LINES ON THE BOLT HEAD.

FIG. 13

TO SHARPEN BLADE (See Fig. 14)

Care should be taken to keep the blade balanced. An unbalanced blade will cause excessive vibration and even- tual damage to mower and engine.

•The blade can be sharpened with a file or on a grinding wheel. Do not attempt to sharpen while on the mower.

•To check blade balance, you will need a 5/8" diameter steel bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions supplied with bal-

ancer).15

BATTERY (See Fig. 15)

Your tractor has a battery charging system which is suffi- cient for normal use. However, periodic charging of the battery with an automotive charger will extend it's life.

•Acid solution level in each battery cell should be even with bottoms of vent wells. Add only distilled or iron free water if necessary. Do not overfill.

•Keep battery and terminals clean.

•Keep battery bolts tight.

•Keep vent caps tight and small vent holes in caps open.

•Recharge at 6 amperes for 1 hour.

TO CLEAN BATTERY AND TERMINALS -

Corrosion and dirt on the battery and terminals can cause the battery to "leak" power.

•Remove terminal guard.

•Disconnect BLACK battery cable first then RED bat- tery cable and remove battery from tractor.

•Wash battery with solution of four tablespoons of baking soda to one gallon of water. Be careful not to get the soda solution into the cells.

•Rinse the battery with plain water and dry.

•Clean terminals and battery cable ends with wire brush until bright.

•Coat terminals with grease or petroleum jelly.

•Reinstall battery (See "INSTALL BATTERY" in the Assembly section of this manual).

CUT AWAY VIEW

VENT CAP

 

VENT

 

WELL

 

BATTERY

 

CELL ACID

 

LEVEL

FIG. 15

 

Page 14 Page 16
Image 15
Page 14 Page 16
Contents YT180 Safe Operation Practices for Ride-On Mowers Safety RulesType Product SpecificationsCustomer Responsibilities Model Number YT180 SerialIndex Contents of Hardware Pack Before Rolling Tractor OFF Skid AssemblyTools Required for Assembly To Remove Tractor from CartonCheck for Proper Position of ALL Belts HOW to SET UP Your TractorCheck Tire Pressure Check Deck LevelnessTo Attach Front Bumper See Fig Install Battery See FigsInstall Mulcher Plate See Figs a & 8B Assemble Gauge Wheels to Mower Deck See FigTo Convert to Bagging or Discharging Know Your Tractor OperationHOW to USE Your Tractor ADD Gasoline Before Starting the EngineTo Operate on Hills To TransportIndicator Lights Mowing TipsTo Start Engine See Fig General Recommendations Maintenance ScheduleLubrication Chart Customer ResponsibilitiesBlade Care TractorBrake Operation TiresLubrication EngineBelts Transaxle CoolingSpark Plugs CleaningEngine OIL Filter MufflerService and Adjustments To Install Mower See FigTo Remove Mower See Fig FRONT-TO-BACK Adjustment See Figs To Level Mower HousingTo Replace Motion Drive Belt See Fig To Adjust Brake See FigBelt Installation To Replace Mower Blade Drive Belt See FigTo Remove Wheel for Repairs See Fig To Adjust Steering Wheel AlignmentTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERInterlocks and Relays To Remove Hood and Grill Assembly See FigTo Replace Fuse To Replace Headlight BulbFinal Setting To Adjust Throttle Control Cable SeeTo Adjust Carburetor See Fig Preliminary SettingOther StorageProblem Cause Correction Troubleshooting PointsOFF 18 HP 42 Tractor - Model Number YT180 954001082A Schematic2221 Electrical Repair PartsChassis and Enclosures Repair Parts Drive Repair Parts Steering Assembly Repair Parts KEY Part Description Seat AssemblyLBD48 DecalsWheels & Tires LSB42Engine Repair Parts Mower Lift Assembly Repair Parts Mower KEY Part NO. no Description Dana Transaxle - Model Number Repair Parts Slope Sighting Guide CUT This OUT Dotted Is aHusqvarna Forest & Garden CO Warranty Statement954 00 532145019 07.08.94

YT180 specifications

The Husqvarna YT180 is a standout lawn tractor, designed for residential homeowners looking for a reliable, efficient, and user-friendly solution for maintaining their lawn. With its powerful performance, ergonomic design, and advanced features, the YT180 delivers an exceptional mowing experience.

At the heart of the YT180 is a robust 18.5 horsepower Briggs & Stratton engine, providing ample power for tackling various terrains and grass lengths. The engine is designed for easy starting and smooth operation, making it an ideal choice for both seasoned users and beginners alike. The cutting deck measures 42 inches, allowing for efficient mowing of medium to large yards while ensuring a clean and precise cut.

One of the key features of the Husqvarna YT180 is its Hydrostatic transmission, which allows for easy speed and direction changes without the need for shifting gears. This seamless operation offers great maneuverability, especially when navigating around obstacles like trees and flowerbeds. The pedal-operated transmission system also helps ensure comfort during operation, reducing fatigue during long mowing sessions.

In addition to its powerful engine and reliable transmission, the YT180 is equipped with an adjustable cutting height feature, which offers a range of settings to suit different grass types and cutting preferences. This versatility makes it easier to achieve the perfect look for your lawn, whether you prefer a clean cut or a more natural look.

The design of the YT180 also prioritizes user comfort and convenience. With an ergonomic seat, easy-access controls, and a spacious foot area, operators will find it easy to maintain a comfortable position while mowing. Moreover, the tractor's sturdy construction ensures durability and longevity, making it a worthwhile investment for homeowners.

Safety features are another priority for Husqvarna, and the YT180 is no exception. It includes a safety switch that stops the blades when the operator leaves the seat, minimizing the risk of accidents. Additionally, the tractor has a reinforced chassis and is compatible with a range of accessories, such as baggers and tow-behind trailers, enhancing its versatility for various lawn care tasks.

In conclusion, the Husqvarna YT180 is a well-rounded lawn tractor that combines power, comfort, and advanced technology. With its impressive engine performance, user-friendly features, and emphasis on safety, it provides homeowners with an effective and enjoyable solution for maintaining their lawns. Whether mowing, bagging, or simply enjoying the ride, the YT180 is designed to meet and exceed the expectations of residential lawn care enthusiasts.
Top Page Image Contents