Husqvarna owner manual Tractor Model NO. YTH24V54, Schematic

Page 29

TRACTOR - MODEL NO. YTH24V54 (289640)

SCHEMATIC

SCH12

A

AMMETER (OPTIONAL)

WHITE

S

B M

	BATTERY	SOLENOID
		SOLENOID	STARTER
			STARTER
	RED		M
RED	FUSE		M
RED
		BLACK
		BLACK
	PTO SWITCH		ELECTRIC CLUTCH
	PTO SWITCH	WHITE	BLACK
	(DISENGAGED)
BLACK	H	WHITE
BLACK
	C

G

A1

GRAY

C F H

B E G

A D

PTO SWITCH

(MATING SIDE)

L A2

BLACK

ORANGE

RED	A	D RED	CLUTCH/BRAKE
	A	D RED	CLUTCH/BRAKE
			(PEDAL UP)
	B	E
		BLACK		REVERSE SWITCH
		BLACK		(NOT IN REVERSE)
				(NOT IN REVERSE)
	BLACK
	BLACK
		2	BLACK
	BLACK	3		SEAT SWITCH
		3	BLACK	(NOT OCCUPIED)
	BLACK	1	BLACK
		1
		6	GRAY
		JUNCTION
		CONNECTOR
	/WHITE			SHORTING
	BLACK			SHORTING
		CHASSIS		CONNECTOR
		CHASSIS
		HARNESS
		IGNITION		SPARK
		UNIT		PLUGS GAP
			(2 PLUGS ON
		(OPTIONAL)	TWIN CYL. ENGINES)
		(OPTIONAL)
	BLUE	HOUR		BLACK
		METER
	FUEL	BLUE		12V	BLACK
	LINE			12V
	LINE
				POWER OUTLET
BLUE				(OPTIONAL)
		CHARGING SYSTEM OUTPUT
	FUEL SHUT-OFF	9 - 1 6 AMP DC @ 3600 RPM
	SOLENOID
	(IF EQUIPPED)	REGULATOR		STATOR
	RED	REGULATOR
	RED
			28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
		BROWN			BLACK
	LIGHT
	SWITCH
			HEADLIGHTS

				3	6	6	3
	IGNITION SWITCH
				2	5	5	2
	POSITION	CIRCUIT	“MAKE”
						4	1
	OFF	M+G+A1		1	4

	RUN/OVERRIDE	B+A1
	RUN	B+A1	L+A2	CHASSIS HARNESS		DASH HARNESS
	START	B + S + A1		CONNECTOR		CONNECTOR
				(MATING SIDE)

WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

NON-REMOVABLE CONNECTIONS

REMOVABLE CONNECTIONS

29

Image 29

Contents 917.289640 Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationGeneral Service ServiceIII. Children IV. TowingTable of Contents Mower Mower Front Wheel Unassembled PartsSlope Sheet KeysTools Required for Assembly AssemblyToremovetractorfromcarton Before Removing Tractor from SkidANTI-SWAY BAR S Install ANTI-SWAY BAR S if Equipped SeeTurn Steering Wheel Left and Position Mower See Fig Attach Front Link E See Fig Attach Mower Side Suspension Arms a to Chassis See FigAttach Rear Lift Links C See Fig Check Tire Pressure Install Belt on Engine Clutch Pulley M SeeCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Reverse Operation System ROS on Position Know Your TractorTo SET Parking Brake See Fig HOW to USE Your TractorStopping See Fig To USE Throttle Control D See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigSystem Characteristics To USE Cruise Control J See FigTo Stop Mower Blades Using the Reverse Operation SystemReverse Operation System ROS To Operate on HillsBefore Starting the Engine Service REMINDER/HOUR MeterCheck Engine OIL Level ADD GasolinePurge Transmission Mowing TipsMaintenance MaintenanceGeneral Recommendations ScheduleTractor BatteryBrake Operation TiresEngine Deck Washout Port See Fig CleaningIN-LINE Fuel Filter See Fig To Install Mower Service and AdjustmentsTo Remove Mower See Fig To Replace Mower Blade Drive Belt See FigTo Level Mower To Check Brake Belt InstallationTo Replace Motion Drive Belt See Fig To Remove Wheel See FigReplacing Battery See Fig To Start Engine with a Weak Battery See FigFront Wheel TOE-IN/CAMBER To Attach Jumper CablesTransmission Other StorageFuel System Engine OILProblem Cause Correction Battery will not To run when operFires when turn Engine continuesTractor Model NO. YTH24V54 SchematicElectrical KEY Part Description ElectricalChassis Tractor Model NO. YTH24V54 197 DriveKEY Part NO. NO. Description Engine 30!2+ª!22%34%2ª+4Engine Power Rating Information Steering Assembly KEY Part NO. NO. Description Mower Deck 532 40 31-25 Deck Weldment Mower Mower Lift Seat Assembly Wheels and Tires DecalsLiquid Gasket and the Breather Gasket are Interchangeable Briggs Engine Model 445677, Type Number 1198-B1Tractor Model NO. YTH24V54 967 628 385 601A 918 240 334 788 387 526 474 693997 Tractor Model NO. YTH24V54 Tufftorq Transaxle Model Number K46BT Tractor - Model Number YTH24V54Tractor - Model Number YTH24V54 Service Notes Service Notes Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationWarranty Statement