American Dryer Corp MDG30V

113365 1- 04/22/02-25

Contents

Main MDG30V (30 lb. Single Pocket) Installation Manual RETAIN THESE INSTRUCTIONS IN A SAFE PLACE FOR FUTURE REFERENCE Retain This Manual In A Safe Place For Future Reference Important Page Page Table of Contents Page SECTION I IMPORTANT INFORMATION IMPORTANT: The dryer must be transported and handled in an upright position at ALL times. A. RECEIVING AND HANDLING B. SAFETY PRECAUTIONS Page SECTION II SPECIFICATIONS Gas A. SPECIFICATIONS Page SECTION III INSTALLATION PROCEDURES A. UNPACKING/SETTING UP IMPORTANT: Dryer must be transported and handled in an upright position at ALL times. B. LOCATION REQUIREMENTS IMPORTANT: The dryer must be installed on noncombustible floors only . IMPORTANT: Dryer should be located where a minimum amount of exhaust duct will be necessary. C. DRYER ENCLOSURE REQUIREMENTS D. FRESH AIR SUPPLY REQUIREMENTS E. EXHAUST REQUIREMENTS SINGLE DRYER VENTING VERTICAL VENTING Illus. B MULTIPLE DRYER (COMMON) VENTING Page IMPORTANT VENTING REMINDERS F. ELECTRICAL INFORMATION NOTE: Component failure due to improper voltage application will VOID THE WARRANTY. IMPORTANT: For personal safety and proper operation, the dryer must be grounded. NOTE: A CIRCUIT SERVICING EACH DRYER MUST BE PROVIDED. SINGLE-PHASE (1) ELECTRICAL CONNECTION LEADS IMPORTANT : A CIRCUIT SERVICING EACH DRYER MUST BE PROVIDED. MDG30 V (GAS ) G. GAS INFORMATION TYPE OF GAS NATURAL LIQUID PROPANE TYPE OF GAS Page Page H. PREPARATION FOR OPERATION/START-UP I. PREOPERATIONAL TESTS J. PREOPERATIONAL INSTRUCTIONS Page Page Page SECTION IV SERVICE/PARTS INFORMA TION A. SERVICE B. PARTS SECTION V WARRANTY INFORMATION A. RETURNING WARRANTY CARDS B. WARRANTY SECTION VI ROUTINE MAINTENANCE A. CLEANING SUGGESTED CLEANING SCHEDULE B. ADJUSTMENTS C. LUBRICATION Page SECTION VII TROUBLESHOOTING MICROPROCESSOR CONTROLLER (COMPUTER) MODELS Page Page Page Q. Dryer operates but is taking too long to dry... R. Condensation on main door glass... S. Dryer is making scraping noise at basket (tumbler) area... T. Excessive noise and/or vibration... U. Main burners are burning with a yellow flame (for gas models only)... Page Page SECTION IX