Manuals / Ariens / Lawn and Garden / Snow Blower

Ariens 921024 quick start Step One Assemble Handlebars Connect Headlight Wire Harness

Models: 921024

1 29

Download 29 pages 8.38 Kb

Page 7

Step One: Assemble Handlebars (Connect Headlight Wire Harness)

Step One: Assemble Handlebars (Connect Headlight Wire Harness)

NOTE: The headlight wire harness comes attached to the upper handlebar assembly.

1.Route the wire harness along the interior of the right side handlebar.

2.Connect to the engine electrical plug.

3.Press cable anchor into mounting hole in the frame near the engine electrical plug.

4.Secure the wire harness to the handlebars using the cable ties attached to the wire harness.

NOTE: This slide applies to

UNATTACHED handlebars ONLY

Image 7

Ariens 921024 quick start Step One Assemble Handlebars Connect Headlight Wire Harness

Contents

Deluxe 24 921024 s/n 101 & up Quick Start GuideNot attached Step One Assemble HandlebarsNOTE This slide applies to UNATTACHED handlebars ONLY Step One Assemble Handlebars Unfold Lower HandlebarNOTE This slide applies to UNATTACHED handlebars ONLY Step One Assemble Handlebars Attach Upper Handlebar AssemblyNOTE This slide applies to UNATTACHED handlebars ONLY Step One Assemble Handlebars Attach Control Cables1. Hook Spring end of attachment control cable to the clutch arm NOTE Make sure the cable remains in the groove of the pulleyNOTE This slide applies to UNATTACHED handlebars ONLY Step One Assemble Handlebars Unfold Upper HandlebarNOTE This slide applies to UNATTACHED handlebars ONLY Step One Assemble Handlebars Connect Headlight Wire HarnessNOTE This slide applies to ATTACHED handlebars ONLY Step One Assemble Handlebar2. Remove mounting hardware from auger housing Step Two Install Discharge Chute1. Grease underside of discharge chute ring if not already greased Step Three Install Discharge Chute Crank Step Four Install Remote Deflector Control Cable Step Five Check Function of Dual Handle Interlock Step Six Check Tire Pressure Skid Shoes in Owners Step Seven Adjust Skid ShoesManual Check oil level in auger gearcase Step Eight Check Auger Gearcase OilIMPORTANT The engine Step Nine Check Engine Crankcase Oil Ariens AXFill fuel tank. DO NOT OVERFILL! See Step Ten Fill Engine Fuel Tank Ariens AXFILLING FUEL TANK in Engine Ariens AX Step Eleven Starting theTurn throttle all the way up. Turn choke ON Starting Engine / Step A ChokePush rocker switch to RUN position Starting Engine / Step B Rocker SwitchTurn fuel petcock to ON position Starting Engine / Step C Fuel Shut Off ValveStarting Engine / Step D Key Starting Engine / Step E Prime Starting Engine / Step F Manual Start Starting Engine / Step F Electric Start Press and hold starter button Starting Engine / Step G Electric StartCHOKE OFF position Starting Engine / Step H Warm up2. Push rocker switch to STOP position 3. Pull safety key OUT Step Twelve Stopping the Engine Ariens AXUnder normal conditions 1. Turn throttle down Refer to Owners Manual and Engine Manual Contact Ariens Company Additional ResourcesE-mail info@ariens.com