Manuals / Ariens / Lawn and Garden / Snow Blower

Ariens 921024 quick start Step One Assemble Handlebars Attach Upper Handlebar Assembly

Models: 921024

1 29

Download 29 pages 8.38 Kb

Page 4

Step One: Assemble Handlebars

Step One: Assemble Handlebars

(Attach Upper Handlebar Assembly)

1.Attach upper handlebar assembly to lower handlebar using two sets of the handlebar hardware. One set to attach each side of the handlebars.

NOTE: DO NOT tighten hardware. Allow upper handlebar assembly to hang from the lower handlebars for the next step.

NOTE: This slide applies to

UNATTACHED handlebars ONLY

Image 4

Ariens 921024 quick start Step One Assemble Handlebars Attach Upper Handlebar Assembly

Contents

Quick Start Guide Deluxe 24 921024 s/n 101 & upStep One Assemble Handlebars Not attachedStep One Assemble Handlebars Unfold Lower Handlebar NOTE This slide applies to UNATTACHED handlebars ONLYStep One Assemble Handlebars Attach Upper Handlebar Assembly NOTE This slide applies to UNATTACHED handlebars ONLYStep One Assemble Handlebars Attach Control Cables 1. Hook Spring end of attachment control cable to the clutch armNOTE Make sure the cable remains in the groove of the pulley NOTE This slide applies to UNATTACHED handlebars ONLYStep One Assemble Handlebars Unfold Upper Handlebar NOTE This slide applies to UNATTACHED handlebars ONLYStep One Assemble Handlebars Connect Headlight Wire Harness NOTE This slide applies to UNATTACHED handlebars ONLYStep One Assemble Handlebar NOTE This slide applies to ATTACHED handlebars ONLY2. Remove mounting hardware from auger housing Step Two Install Discharge Chute1. Grease underside of discharge chute ring if not already greased Step Three Install Discharge Chute Crank Step Four Install Remote Deflector Control Cable Step Five Check Function of Dual Handle Interlock Step Six Check Tire Pressure Skid Shoes in Owners Step Seven Adjust Skid ShoesManual Step Eight Check Auger Gearcase Oil Check oil level in auger gearcaseStep Nine Check Engine Crankcase Oil Ariens AX IMPORTANT The engineFill fuel tank. DO NOT OVERFILL! See Step Ten Fill Engine Fuel Tank Ariens AXFILLING FUEL TANK in Step Eleven Starting the Engine Ariens AXStarting Engine / Step A Choke Turn throttle all the way up. Turn choke ONStarting Engine / Step B Rocker Switch Push rocker switch to RUN positionStarting Engine / Step C Fuel Shut Off Valve Turn fuel petcock to ON positionStarting Engine / Step D Key Starting Engine / Step E Prime Starting Engine / Step F Manual Start Starting Engine / Step F Electric Start Starting Engine / Step G Electric Start Press and hold starter buttonStarting Engine / Step H Warm up CHOKE OFF position2. Push rocker switch to STOP position 3. Pull safety key OUT Step Twelve Stopping the Engine Ariens AXUnder normal conditions 1. Turn throttle down Refer to Owners Manual and Engine Manual Contact Ariens Company Additional ResourcesE-mail info@ariens.com