Black & Decker 90515795 Battery Replacement/Disposal, Safe Battery Disposal, Warnings

SL102B_ManualEN_051007.qxp 5/10/07 9:13 AM Page 5

1.Disconnect the unit from any charging adapters.

2.Push the rubber bezel forward toward the front of the spotlight to reveal two small Phillips screws in the retaining ring.

3.Using the screwdriver, remove (counterclockwise) the two screws. Set them aside.

4.Lift off the retaining ring, glass lens and rubber “O” ring and set them aside.

5.Carefully remove the reflector and bulb assembly.

HAIRPIN RETAINING

WIRES

PHILLIPS

HEAD

SCREWS

BULB

REFLECTOR

6.Disconnect the bulb wire from the red power wire.

7.Unsnap the hairpin retaining wires from the reflector’s flange.

8.Using the screwdriver, loosen the retaining screw to remove the bulb from the reflector (no need to completely remove this screw).

9.Lift out the bulb and detach wire.

10.Insert the replacement bulb into the reflector’s flange.

11.Put back and secure the hairpin retaining wires.

12.Connect the bulb power wire to the red power wire.

13.Tighten the retaining screw on the flange.

14.Place the reflector in position in the body of the spotlight.

15.Replace the rubber “O” ring in the groove around the perimeter of the reflector.

16.Replace glass and retaining ring so the screw holes are aligned.

17.Secure retaining ring with two screws.

18.Replace rubber bezel.

19.Operate switch to ensure proper operation of spotlight.

WARNING: To reduce the risk of electric shock, replace bulb with 6 volt H3 55 watt only.

Battery Replacement/Disposal

Battery Replacement

The battery should last the service life of the unit. Contact Technical Support toll-free at 1-800-544- 6986 for any information you may need.

Safe Battery Disposal

Contains a maintenance-free, sealed, non-spillable, lead acid battery, which must be disposed of properly. Recycling is required, contact your local authority for information. Failure to comply with local, state and federal regulations can result in fines, or imprisonment.

WARNINGS:

•Do not dispose of the battery in fire as this may result in an explosion.

•Before disposing of the battery, protect exposed terminals with heavy-duty electrical tape to prevent shorting (shorting can result in injury or fire).

•Do not expose battery to fire or intense heat as it may explode.

•For more information on recycling this battery, call toll-free (877) 288-7722.

5