DON'T OVERLOAD
GENERATOR
Capacity
You must make sure your generator can supply enough rated (running) and surge (starting) watts for the items you will power at the same time. Follow these simple steps:
1.Select the items you will power at the same time.
2.Total the rated (running) watts of these items. See Figure 6.
3.Estimate how many surge (starting) watts you will need. Surge wattage is the short burst of power needed to start electric
For Example:
Tool or Appliance | Rated (Running) |
| Additional Surge |
Watts |
| (Starting) Watts | |
|
| ||
|
|
|
|
Refrigerator | 800 |
| 1600 |
|
|
|
|
Deep Freezer | 500 |
| 500 |
|
|
|
|
Television | 500 |
| - |
|
|
|
|
Light (75 Watts) | 75 |
| - |
|
|
| |
| 1875 Total Running | 1600 Highest Surge | |
| Watts |
| Watts |
|
|
|
|
Total Rated (Running) Watts | = 1875 | ||
Highest Additional Surge Watts | = 1600 | ||
Total Generator Output Required | = 3475 | ||
Power Management
It is important to take care when adding electrical loads to your generator.The correct and safe way to manage generator power is to sequentially add loads as follows:
1.With nothing connected to the generator, start the engine as described in this manual.
2.Plug in and turn on the first load, preferably the largest load you have.
3.Permit the generator output to stabilize (engine runs smoothly and attached device operates properly.
OPERATION
4.Plug in and turn on the next load.
5.Again, permit the generator to stabilize.
6.Repeat steps 4 and 5 for each additional load.
NEVER add more loads than generator capacity.Take special care to consider surge loads in generator capacity, as described above.
Figure 6 - Wattage Reference Chart
| Rated* | Additional | |
| Surge | ||
Tool or Appliance | (Running) | ||
(Starting) | |||
| Watts | ||
| Watts | ||
|
| ||
Essentials |
|
| |
Light Bulb - 75 watt | 75 | - | |
Deep Freezer | 500 | 500 | |
Sump Pump | 800 | 1200 | |
Refrigerator/Freezer - 18 Cu. Ft. | 800 | 1600 | |
Water Well Pump - 1/3 HP | 1000 | 2000 | |
Heating/Cooling |
|
| |
Window Fan | 300 | 600 | |
Furnace Fan Blower - 1/2 HP | 800 | 1300 | |
Kitchen |
|
| |
Microwave Oven - 1000 Watt | 1000 | - | |
Coffee Maker | 1500 | - | |
Electric Stove - Single Element | 1500 | - | |
Hot Plate | 2500 | - | |
Family Room |
|
| |
Stereo Receiver | 450 | - | |
Television - 27” | 500 | - | |
Personal Computer w/17” monitor | 800 | - | |
Other |
|
| |
AM/FM Clock Radio | 300 | - | |
Electric Water Heater - 40 Gallon | 4000 | - | |
Quartz Halogen Work Light | 1000 | - | |
Airless Sprayer - 1/3 HP | 600 | 1200 | |
Reciprocating Saw | 960 | 960 | |
Electric Drill - 1/2 HP | 1000 | 1000 | |
Circular Saw - 7 1/4” | 1500 | 1500 | |
Miter Saw - 10” | 1800 | 1800 | |
Table Saw/Radial Arm Saw - 10” | 2000 | 2000 | |
Air Compressor - | 2500 | 2500 | |
|
|
|
*Wattages listed are approximate only. Check tool or appliance for actual wattage.
12
