BSP5500L Generator
TABLE OF CONTENTS
Safety Rules. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Know Your Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Product Specifications / Maintenance . . . . . . . . . . . . . . . . 9
Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 & 17
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Schematic/Wiring Diagram . . . . . . . . . . . . . . . . . . . .
Replacement Parts. . . . . . . . . . . . . . . . . . . . . . . . . . .
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Last Page
EQUIPMENT
DESCRIPTION
Read this manual carefully and become familiar with your generator. Know its applications, its limitations and any hazards involved.
This generator is an
CAUTION! Do Not exceed the generator’s wattage/amperage capacity. See “Don’t Overload the Generator” on page 8.
Every effort has been made to ensure that information in this manual is accurate and current. However, Briggs & Stratton reserves the right to change, alter or otherwise improve the product and this document at any time without prior notice. The Emission Control System for this generator is warranted for standards set by the Environmental Protection Agency. For warranty information refer to the engine owner’s manual.
SAFETY RULES
The safety alert symbol (
) is used with a signal word (DANGER, CAUTION,WARNING), a pictorial and/or a safety message to alert you to hazards. DANGER indicates a hazard which, if not avoided, will result in death or serious injury. WARNING indicates a hazard which, if not avoided, could result in death or serious injury. CAUTION indicates a hazard which, if not avoided, might result in minor or moderate injury. CAUTION, when used without the alert symbol, indicates a situation that could result in equipment damage. Follow safety messages to avoid or reduce the risk of injury or death.
WARNING
The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.
DANGER
Running generator gives off carbon monoxide, an odorless, colorless, poison gas.
Breathing carbon monoxide will cause nausea, fainting or death.
•Operate generator ONLY outdoors.
•Keep at least 2 feet of clearance on all sides of generator for adequate ventilation.
•Do not operate generator inside any building or enclosure, including the generator compartment of a recreational vehicle (RV).
DANGER
Failure to properly ground generator can result in electrocution, especially if the generator is equipped with a wheel kit.
•National Electric Code requires generator to be properly grounded to an approved earth ground. Call an electrician for local grounding requirements.
DANGER
Generator produces powerful voltage.
Failure to isolate generator from power utility can result in death or injury to electric utility workers due to backfeed of electrical energy.
•When using generator for backup power, notify utility company. Use approved transfer equipment to isolate generator from electric utility.
•Use a ground circuit fault interrupter (GFCI) in any damp or highly conductive area, such as metal decking or steel work.
•Do not touch bare wires or receptacles.
•Do not use generator with electrical cords which are worn, frayed, bare or otherwise damaged.
•Do not operate generator in the rain.
•Do not handle generator or electrical cords while standing in water, while barefoot, or while hands or feet are wet.
•Do not allow unqualified persons or children to operate or service generator.
2
