Before motor is removed, it should be tested to be sure it is inoperative. Check the continuity of the motor.
CHECK CONTINUITY |
|
Black to Orange | If open, replace motor |
Red to Orange | If open, replace motor |
Gray to Orange | If open, replace motor |
Green to Motor Frame | If open, inspect wire to |
| be sure it is properly |
| attached to motor |
| frame |
1.Lower ram manually until there is approximately 7" between the bottom assembly and the ram.
2.Disconnect molex connector from motor to wire harness.
3.Using a 3/8" nut driver or socket, remove the four nuts hold- ing the motor to the gearbox. Remove air scentry tray and pull motor out through front of compactor.
4.Install motor in reverse procedure.
BLACK GRAY
RED GREEN
ORANGE
EMERSON MOTOR
93030201
CENTRIFUGAL SWITCH
(USED ON EMERSON MOTOR)
BROWN
|
|
|
|
|
| YELLOW | |
|
|
|
|
WHITE |
|
|
|
| BLUE |
| |
|
|
| |
|
|
|
|
| SCHEMATIC SHOWS UNIT AT END |
| L1 | ||||
R | OF CYCLE - IN TOP POSITION |
|
|
| |||
|
| DRAWER OPEN |
|
|
| ||
TR |
|
|
|
| BK | ||
V |
|
| BK (or BR) |
|
|
| |
|
|
|
|
|
|
| |
| START |
|
|
| C | NC | |
Y |
|
|
| BL/W |
|
| |
| C |
|
|
|
| ||
| BL | NO | BL/W |
|
| NO | |
KEY |
|
|
| ||||
|
|
|
| ||||
|
|
|
|
|
| ||
|
|
|
|
|
|
| |
SWITCH |
|
| NC |
|
| C |
|
|
|
| Y |
| NC | ||
|
|
|
|
| |||
|
|
|
|
|
| ||
R |
| C | NO | BR |
|
| NO |
|
|
|
| ||||
|
|
|
|
| |||
|
|
|
| TOP LIMIT | |||
|
|
| NC |
| |||
|
|
|
| SWITCH | |||
|
| INTERLOCK |
|
|
|
| |
|
| SWITCH |
|
|
|
| |
USAS SYMBOLS |
|
|
|
|
| ||
|
|
|
|
| 1 |
| Y |
|
|
|
|
| 2 |
| |
NC |
| NC |
|
|
|
| |
|
|
| 3 |
| TR | ||
HELD OPEN |
|
|
|
| 4 |
| |
|
|
|
|
|
| ||
|
|
|
|
|
|
| |
|
|
|
|
| 5 |
|
|
NO |
|
|
| MOTOR |
|
|
|
| NO |
| PLUG |
|
|
| |
HELD CLOSED |
|
|
|
|
|
|
|
8
GN |
|
| W |
|
| W |
|
| SAFETY SWITCH | ||||
|
|
| ||||
|
|
| GN |
| NO |
|
|
| 4 | Y | C | BR 5 | OR |
|
| GN |
|
| ||
|
|
|
| SPEED |
| |
V | 2 | BK | CW START UP | SWITCH |
| |
|
|
| ||||
OR | 1 | R CCW START DOWN |
| OL |
| |
|
|
| ||||
BR | 3 | GY | RUN |
|
|
|
|
|
|
| |||
MOTOR
| NC | NO | C |
|
| ||
|
|
| |
| V |
| C |
|
|
| |
| NC |
|
|
OFF - ON |
| C |
|
START - RUN |
|
|
|
KEY SWITCH |
|
| NO |