Manuals / Bryant / Household Appliance / Furnace

Bryant 313AAV instruction manual SEE NOTES 1,2,4,5,7,8,9, then Up

Models: 313AAV

1 54

Download 54 pages 25.56 Kb

Page 33

Image 33

SEE NOTES: 1,2,4,7,8,9 on the page following these figures

A03214

Fig. 42 - Horizontal Right Application-Vent Elbow Right

SEE NOTES: 1,2,4,5,7,8,9 on the page following these figures

A03215

Fig. 43 - Horizontal Left Application-Vent Elbow Up

SEE NOTES: 1,2,4,5,7,8,9 on the page following these figures

A03219

Fig. 44 - Horizontal Right Application-Vent Elbow Left

then Up

SEE NOTES: 1,2,4,5,7,8,9 on the page following these figures

A03216

Fig. 45 - Horizontal Left Application-Vent Elbow Right

313A

SEE NOTES: 1,2,4,5,7,8,9

A02068

Fig. 46 - Horizontal Right Application-Vent Elbow Left

Page 33

Image 33

Bryant 313AAV instruction manual SEE NOTES 1,2,4,5,7,8,9, then Up

Contents

Installation, Start-up,Operating and Service and Maintenance Instructions Series 100/A313AAV/JAV PLUS 313A SAFETY CONSIDERATIONSFig. 1 - Dimensional Drawing Table 1 - Dimensions FURNACE RELIABILITY HAZARDINTRODUCTION 313ACUT HAZARD CODES AND STANDARDS 313AFig. 2 - Clearances to Combustibles Fig. 3 - Return Air Temperature ELECTROSTATIC DISCHARGE ESD PRECAUTIONS PROCEDUREGeneral Installation Gas Piping and Gas Pipe Pressure Testing313A LOCATIONFig. 4 - Multipoise Orientations GENERAL313A Fig. 5 - Installation in a GarageELECTRICAL OPERATION HAZARD PERSONAL INJURY AND/OR PROPERTY DAMAGE HAZARDFig. 6 - Prohibit Installation on Back AIR FOR COMBUSTION AND VENTILATION313A FIRE HAZARDVolume Volume21ft3 1000 Btu/hrUPFLOW INSTALLATION INSTALLATION313A or sealed andFig. 11 - Floor and Plenum Opening Dimensions DOWNFLOW INSTALLATION313A Fig. 10 - Leveling LegsCoil Box Installed on a Combustible Floor Fig. 13 - Furnace, Plenum, and Coil Assembly orFURNACE APPROVED COIL ASSEMBLY OR COIL BOX 313AHORIZONTAL INSTALLATION Table 4 - Opening Dimensions - In. mm313A Suspended Furnace SupportSide Return Air Inlet 313AFILTER ARRANGEMENT CARBON MONOXIDE AND POISONING HAZARD313A UPFLOWDOWNFLOW HORIZONTALFig. 14 - Duct Flanges Fig. 15 - Horizontal Unit SuspensionFig. 17 - Typical Attic Installation 313AFig. 16 - Horizontal Suspension with Straps Return Air Connections 313AFIRE HAZARD GAS PIPING313A Table 5 - Air Delivery - CFM With FilterTable 6 - Maximum Capacity of Pipe 313A A02075A02163 Fig. 21 - Burner and Manifold 313A2” 51mm Street Elbow A02162Table 7 - Electrical Data 313AFig. 22 - Typical Gas Pipe Arrangement ELECTRICAL CONNECTIONS313A 115-VWIRINGFURNACE MAY NOT OPERATE FIRE HAZARDBX CABLE INSTALLATION IN FURNACE J-BOX POWER CORD INSTALLATION IN FURNACE J-BOX24-VWIRING ACCESSORIESFig. 24 - Furnace Control 313ACARBON MONOXIDE POISONING HAZARD 313AGENERAL VENTING REQUIREMENTS MASONRY CHIMNEY REQUIREMENTSditioner 313Ationer Pump Dual Fuel313A NOTES FOR FIGURESand Single-SpeedHeat Pump and Two-SpeedHeat PumpConnectors NFPA & AGA Installations with Type-BDouble Wall Vent313A Exterior Masonry Chimney FAN + NAT313A CHIMNEY INSPECTION CHARTADDITIONAL VENTING REQUIREMENTS 313ACUT HAZARD BURN HAZARDFig. 34 - Upflow Application-VentElbow Up 313AFig. 35 - Upflow Application-VentElbow Right Fig. 37 - Downflow Application-VentElbow Upfollowing these figures SEE NOTES 1,2,4,5,7,8,9 on the page313A SEE NOTES 1,2,4,5,6,7,8,9313A SEE NOTES 1,2,4,5,7,8,9then Up Fig. 47 - Using Tin Snips to Cut Tie Points 313AVenting Notes for Figures Fig. 48 - Rounded End of Knockout 313AFig. 49 - Knockout Pulled Loose Fig. 51 - Remove Knockout with HammerStart-UpProcedures START-UP,ADJUSTMENT, AND SAFETY CHECKAdjustments 313AIn Canada 313Afollow exclusively the National Fuel Gas Code Table 10 - Altitude Derate Multiplier for U.S.AELECTRICAL SHOCK HAZARD 313AFig. 52 - Gas Control Valve Fig. 53 - Orifice Hole313A Check Safety ControlsTable 11 - Speed Selection FURNACE OVERHEATING HAZARD1.Put away tools and instruments. Clean up debris Checklist313A Table 12 - Gas Rate Cu Ft./HrA08220 313AA08220A 313AELECTRICAL CONTROLS AND WIRING SERVICE AND MAINTENANCE PROCEDURESINTRODUCTION 313AA08221 313AFig. 55 - Service Label SERVICE313A STATUSCLEANING AND/OR REPLACING AIR FILTER CARE AND MAINTENANCE313A FIRE OR EXPLOSION HAZARD313A CLEANING HEAT EXCHANGERUNIT DAMAGE HAZARD ELECTRICAL SHOCK HAZARD313A Fig. 56 - Igniter Position-SideViewFig. 57 - Igniter Position-TopView 313A Fig. 58 - Cleaning Heat Exchanger CellFIRE OR EXPLOSION HAZARD Sequence of Operation2.Cooling Mode 313Ab.Two-SpeedCooling 3.Thermidistat ModeTroubleshooting Wiring Diagrams313A 5.Heat pumpFig. 59 - Wiring Diagram 313AA08176 Fig. 60 - Troubleshooting Guide 313ASTART 313A Catalog No. II313AAV---03Adapter Kit