INSTALLATION STEP 8

Install the Lights

ïInstall up to a 100 watt maximum light bulb in each socket. The lights will turn ON and remain lit for approximately 4-1/2 minutes when power is connected. Then the lights will turn OFF.

ïInsert bottom lens tabs into slots on chassis. Tilt towards chassis to engage top tabs, then drop down gently into place.

ïTo remove, depress both top lens tabs. Tilt lens slightly outward and down, then pull out to clear bulbs. Use care to avoid snapping off bottom lens tabs.

ïReverse the procedure to close the lens.

ïIf the bulbs burn out prematurely due to vibration, replace with a Garage Door Opener bulb.

NOTE: Use only standard light bulbs. The use of short neck or speciality light bulbs may overheat the endpanel or light socket.

CAUTION

To prevent possible OVERHEATING of the endpanel or light socket,

•DO NOT use short neck or specialty light bulbs.

•DO NOT use halogen bulbs. Use ONLY incandescent.

Top Lens Tab

Lens

Bottom

Lens Tab

Top

Chassis

Slot

Bottom

Chassis Slots

Top

Lens Tab

Top

 

Chassis Slot

 

 

Lens

Bottom

Insert Bottom

Chassis Slot

Lens Tabs First

INSTALLATION STEP 9

Attach the Emergency Release Rope and Handle

ïThread one end of the rope through the hole in the top of the red handle so ìNOTICEî reads right side up as shown. Secure with an overhand knot at least 1" (2.5 cm) from the end of the rope to prevent slipping.

ïThread the other end of the rope through the hole in the release arm of the outer trolley.

ïAdjust rope length so the handle is 6 feet (1.83 m) above the floor. Secure with an overhand knot.

NOTE: If it is necessary to cut the rope, heat seal the cut end with a match or lighter to prevent unraveling.

WARNING

To prevent possible SERIOUS INJURY or DEATH from a falling garage door:

•If possible, use emergency release handle to disengage trolley ONLY when garage door is CLOSED. Weak or broken springs or unbalanced door could result in an open door falling rapidly and/or unexpectedly.

•NEVER use emergency release handle unless garage doorway is clear of persons and obstructions.

•NEVER use handle to pull door open or closed. If rope knot becomes untied, you could fall.

Trolley

Release Arm

Overhand

Emergency Knot

Release Handle

17