Manuals
/
Char-Broil
/
Outdoor Cooking
/
Gas Grill
Char-Broil
463257010 manual Warranty Registration Department, P.O. Box Columbus, GA
Models:
463257010
1
31
32
32
Download
32 pages
5.13 Kb
25
26
27
28
29
30
31
32
<
>
Troubleshooting
Install
Parts list
Parts Diagram
cannot be stopped do not try to repair. Call for replacement
Warranty
Leak test new and exchanged LP cylinders BEFORE connecting to grill
Problem
steps should be taken first to reset the gas regulator safety
If you have questions or need assistance during assembly
Page 31
Image 31
Warranty Registration Department
P.O. Box 1240
Columbus, GA
31902-1240
31
Page 30
Page 32
Page 31
Image 31
Page 30
Page 32
Contents
Date Purchased
Estimated assembly time 30 minutes
please call
Serial Number
DANGER
INSTALLER/ASSEMBLER
TABLE OF CONTENTS
Safety Symbols
CALIFORNIA PROPOSITION
Installation Safety Precautions
Wash your hands after handling this product
Lava Rock / Briquettes
Temperature
GRILLING GUIDE - Getting Started
First Time Use
Indirect Cooking
Food Safety
GRILLING GUIDE - Grilling
Direct Cooking
Sauces
USDA Recommended Safe Minimum Internal Temperatures
Internal Meat Temperatures
GRILLING GUIDE - Tips & Tricks
Routine Care
GRILLING GUIDE - Cleaning Your Grill
Why Clean?
General Cleaning
LP Liquefied Petroleum Gas
USE AND CARE
Never fill a cylinder beyond 80% full
LP Cylinder Removal, Transport and Storage
LP Cylinder Leak Test
Leak test new and exchanged LP cylinders BEFORE connecting to grill
For your safety
LP Cylinder Exchange
Do not use grill until leak-tested
Outdoor gas appliance is not intended to be installed in or on a boat
Outdoor gas appliance is not intended to be installed in or on an RV
Leak Testing Valves, Hose and Regulator
Do not block holes in sides or back of grill
Safety Tips
For Safe Use of Your Grill and to Avoid Serious Injury
Do not let children operate or play near grill
Match-Lighting
Turn controls and gas source or tank OFF when not in use
General Grill Cleaning
Ignitor Lighting continued
1. Turn gas OFF at control knobs and LP cylinder
Cleaning the Burner Assembly
Storing Your Grill
VERY IMPORTANT Burner tubes must reengage valve
TYPE OF FAILURE COVERAGE
LIMITED WARRANTY
SCOPE OF COVERAGE
PERIOD OF COVERAGE
Description
PARTS LIST
Not Pictured
Key Qty Description
XX CC
PARTS DIAGRAM
UU DD HH ZZ
N N O
Fixed caster
ASSEMBLY
Front
Rear
Grill head Regulator hose
Lower back panel 1/4-20x1/2” screw
7mm lock washer 7mm flat washer
Page
Install bezel with “OFF” at top
Note Use left and right holes on fascia to attach valve bracket
Note Use upper and lower holes on fascia to attach bezel
Fully tighten lower screws on upper back panel
Sideburner drip pan Burner tube
Sideburner grate Sideburner Ignitor Wire
Sideburner burner
drip pan Wing nut
Front brace
self-tapping screw
Cart lower back panel
Door Hinge Pin
Heat shield
Wire
Note Some parts omitted for clarity of illustration
Note Some parts omitted for
clarity of illustration
Flametamers
Grease tray
Cylinder screw at rear of cart
AA Battery + Electronic Ignition Cap
GAS ISSUES
Troubleshooting
Prevention/Solution
Problem
AUTO-CLEAN
Troubleshooting continued
Problem
Prevention/Solution
Prevention/Solution
Troubleshooting - Electronic Ignition
Problem Ignition
Check Procedure
Page
P.O. Box Columbus, GA
Warranty Registration Department