Ignitor Lighting (continued)

8.For grills equipped with ELECTRONIC IGNITION at each burner:

Repeat steps 4 through 6 to light each burner.

9.Once each burner has ignited, turn knobs to desired setting.

WARNING

Turn controls and gas source or tank OFF when not in use.

CAUTION

If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Match-Lighting

sDo not lean over grill while lighting.

1.Open lid. Turn ON gas at LP cylinder.

2.Place match into match holder (hanging from side panel of grill). Light match; then light burner by placing match through the match light hole on right or left side of grill.

3.Push in and turn far right or far left burner knob to the HI position, depending on match light hole selected. Be sure burner lights and stays lit.

4.Light adjacent burners in sequence by pushing knobs in and turning to the HI position.

Sideburner Ignitor Lighting

sDo not lean over grill while lighting.

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Turn sideburner knob to the HI position, push and hold ELECTRONIC IGNITOR button.

3.If sideburner does NOT light within 5 seconds, turn knob to OFF, wait 5 minutes, then

repeat lighting procedure.

Sideburner Match Lighting

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Place lit match near burner.

3. Turn sideburner knob to the HI position.

Be sure burner lights and stays lit.

Burner Flame Check

•Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position than seen on HI. Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

HI

LOW

Turning Grill Off

•Turn all knobs to the OFFposition. Turn LP cylinder OFF by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time between each collector box or burner and electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP cylinder before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LOW position then turn back to OFF position. Valves should turn smoothly.

Hose Check

•Before each use, check to see if hoses are cut or worn. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

useDo not citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

•Stainless steel surfaces: To maintain your grill’s high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft cloth after each use. Baked-on grease deposits may require the use of an abrasive plastic cleaning pad. Use only in direction of brushed finish to avoid damage. Do not use abrasive pad on areas with graphics.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

8

Page 7 Page 9
Page 8
Image 8
Char-Broil 463257111 manual Sideburner Ignitor Lighting, Sideburner Match Lighting, Burner Flame Check, Turning Grill Off
Page 7 Page 9

463257111 specifications

The Char-Broil 463257111 is a robust and versatile gas grill that has gained popularity among both novice and experienced grillers. Designed with practicality and ease of use in mind, this grill features a variety of attributes that enhance the grilling experience, making it a worthy addition to any backyard setup.

One of the defining features of this gas grill is its high-quality construction. It boasts a durable stainless steel frame that not only ensures longevity but also provides resistance against rust and corrosion. The grill has a sleek appearance that complements any outdoor decor, though its practical design is just as significant as its aesthetics.

The Char-Broil 463257111 is equipped with four main burners, each providing 10,000 BTUs of heating power. This allows for a total cooking power of 40,000 BTUs, giving users ample heat for grilling various types of meat and vegetables. The burners are outfitted with electronic ignition systems for quick and reliable startups, allowing you to get grilling without the hassle of matches or lighters.

The cooking surface of the Char-Broil 463257111 is generous, providing 425 square inches of primary cooking space, along with an additional 150 square inches of warming rack. This ample cooking area is perfect for hosting gatherings or family barbecues, enabling users to cook enough food for several guests simultaneously.

One standout feature of this grill is its TRU-Infrared cooking technology. This innovative system promotes even heat distribution, ensuring that food cooks uniformly, preventing hotspots that can lead to uneven cooking. The infrared technology not only enhances flavor by sealing in juices, but it also reduces flare-ups, leading to a more controlled cooking environment.

Additionally, the grill features side shelves that offer extra prep space for condiments and tools, while the built-in thermometer allows for precise monitoring of cooking temperatures. This function is crucial for achieving the perfect cook on different types of meat.

Ease of maintenance is another characteristic of the Char-Broil 463257111. The grill is easy to clean, with removable grease trays simplifying the cleanup process after cooking, ensuring that you can spend more time enjoying your meals rather than cleaning.

In conclusion, the Char-Broil 463257111 is an exemplary gas grill that combines quality construction, powerful performance, and innovative technology. Whether you are an ardent grilling enthusiast or a casual cook, this grill provides everything you need for a successful outdoor cooking experience.
Top Page Image Contents