Troubleshooting (continued)
Problem | Possible Cause | Prevention/Solution | |
|
|
| |
Burner will not light | • Rotary knob rotates without clicking. | • Replace knob. | |
using ignitor. | • Sparking between ignitor and electrode. | • Inspect wire insulation and proper connection. Replace wire if | |
| |||
|
| insulation is broken. | |
|
|
| |
| • See “GAS ISSUES:” on previous page. |
| |
Burner will not match | • Match will not reach. | • Use | |
light. | • Improper method of | • See | |
| |||
|
|
| |
Sudden drop in gas | • Out of gas. | • Check for gas in LP cylinder. | |
flow or low flame. | • Excess flow valve tripped. | • Turn off knob, wait 30 seconds and light fryer. If flames are still low, | |
| |||
|
| turn off knob and LP cylinder valve. Disconnect regulator. | |
|
| Reconnect regulator and | |
|
| 30 seconds and then light fryer. | |
| • Vapor lock at coupling nut/LP cylinder | • Turn off knob and LP cylinder valve. Disconnect coupling nut from | |
| connection. | cylinder. Reconnect and retry. | |
|
|
| |
Flames blow out. | • Low on LP gas. | • Refill LP cylinder. | |
| • Excess flow valve tripped. | • Refer to “Sudden drop in gas flow” above. | |
|
|
| |
• Grease buildup. | • Clean burner and inside of fryer body. | ||
| • Excessive fat in meat. | • Trim fat from meat before grilling. | |
| • Excessive cooking temperature. | • Adjust (lower) temperature accordingly. | |
|
|
| |
Persistent grease fire. | • Grease trapped by food buildup around | • Turn knob to OFF. Turn gas off at LP cylinder. Let fire burn out. After | |
| burner system. | fryer cools, remove and clean all parts. | |
|
|
| |
Flashback... | • Burner and/or burner tube is blocked. | • Turn knob to OFF. Clean burner and/or burner tube. See burner | |
(fire in burner tube). |
| cleaning section of Use and Care. | |
|
|
| |
Unable to fill LP | • Some dealers have older fill nozzles | • The worn nozzles don’t have enough “bite” to engage the valve. Try | |
cylinder. | with worn threads. | a second LP dealer. | |
|
|
| |
Cooking slower than | • High wind conditions | • Relocate cooker to a less windy area | |
• Vapor Lock | • Turn off knob and disconnect coupling nut from LP cylinder. | ||
expected | |||
|
| Reconnect and retry. | |
| • Valve not properly aligned to burner | • Loosen control panel and valve. Be sure valve is centered top to | |
|
| bottom and left to right in burner tube. Tighten all components | |
|
| once proper alignment is achieved. | |
|
|
|
Certified Grill Parts And Accessories®,
Artisan Collection by
TEC™ is a registered trademark of TEC
Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391; 4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106; 5,421,319; 5,441,226; 5,452,707; 5,458,309; 5,566,606; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797; 5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644B1; 6,279,566; 6,397,731; 6,418,923; 6,439,222; 6,523,461; D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043; D413,229; D413,229; D414,982; D415,388; D416,164; D416,441; D416,441; D417,587; D422,516; D423,274; D423,876; D428,303; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615; D448,616; D448,975; D449,492; D451,759; D456,202S; D460,313, D461,359 and D504,048. Canada: 87743; 87744; 92607; 92608 and 1,316,424. Other Patents Pending. Assembly instructions © 2007.
07101378 • 17