Coleman 5310, 5300

ÖÖAssemble the Electrode

Wires and the Battery to the

Electrode Module.

Note: The fuel hoses are not

shown in this step, for

simplicity.

14-A

Side Burner Wire

Top Burner Wires

Electrode Module

14-A. Slip the Top Burner Wires through the

large hole in the Top Panel.

ÖÖSlip the Side Burner Wire through the

large hole in the Left Panel.

ÖÖFirmly push the Electrode Wires into

the Electrode Module.

ÖÖAssemble the 9-Volt Battery to the

Electrode Module.

Note: The polarity is marked on the Electrode

Module.

Step

9-Volt Battery

14-B

Side Burner Wire

Igniter Button Wires

(Note: Large Tabs)

9-Volt

Battery

Electrode

Module

TEST THE IGNITER:

A SPARK SHOULD APPEAR AT

ELECTRODE TIP.

IF THE SPARK DOES NOT

APPEAR:

-CHECK THE WIRE

CONNECTIONS TO THE

MODULE.

-CHECK PROPER

ASSEMBLY OF FRESH

9-VOLT BATTERY.

Top

Burner

Wires

Contents

Main Gas Barbecue Use, Care & Assembly Manual With Grill Lighting Instructions 5300 LP Gas Series 5310 Natural Gas Series ASSEMBLER/INSTALLER: CONSUMER/USER: Contents General Safety Information IF YOU SMELL GAS: 13 2 General Installation 8 56 9a 7 WARNING Cylinder Specifications L.P. Gas Cylinder L.P. Gas Cylinder Hose and Regulator Transporting the Cylinder Take these instructions to the L.P. gas dealer. TYPE 1 Transporting the Cylinder CGA-510 POL Filling and Purging Type 1 L.P. Gas Cylinders Purging and Evacuating Devices for L.P. Gas Cylinders with Type 1 Cylinder Valves Filling and Purging Type 1 L.P. Gas Cylinders Assembly/Set up LOOSELYassemble the Right Tighten all fasteners. NOTE: Use a large piece of cardboard or a ground 1-B Assemble the Right Panel and the Left Panel to the NOTE: The four Caster Brackets are Tighten all fasteners. 2-A 2-B Assemble two Non-Locking Casters to the rear of the 3-A Carefully turn the assembly 3-C Assemble the Rear Panel. Assemble the Cylinder 3-B 4-A Attach Electrode Module. Install Door Magnet. 4-B Assemble two Spacers to Assemble the Top Panel to 5-A 5-B 6-A Page NOTE: The Grill Lid Assemble Right Side 7-A Place the Right Side Table against the Firebox and on top 7-B Page Assemble Left Side 8-A 8-B Assemble two screws (TN) through the back flange of the Left Side Burner Table into the Assemble two screws (TN) through the front flange of the Left Side Burner Table into the Page Fasten the Rear Trim Plate NOTE: On some models, 9-A Tighten all 9-B Page Page Page Page Page Install Side Burner Knob 15-A Place the Side Burner Grate on the Left Side Burner. Assemble the Grease Cup 16-A Page Attach an LP Cylinder to the 18-A 18-B 18-C IMPORTANT! WARNING: Attach a NATURALGAS Connecting Type 1 L.P. Gas Cylinders Leak Testing Leak Testing Fixing A Fuel Leak How to Check for Leaks Fixing A Fuel Leak Start-Up Check List Control Knobs for Main Cooking Area JKH REPRESENTATIVE ILLUSTRATION THE FOLLOWING RULES MUST ALWAYS BE FOLLOWED IN THIS ORDER (Fig. 18): Lighting Main Burners Lighting Side Burner Match Lighting - Side Burner 20 20a Shutting Off the Grill Grilling Tips and Hints Yellow Cooking Methods Blue Holes in Burner Yellow Blue Cleaning the Venturi Note: REPRESENTATIVE ILLUSTRATION Cleaning and Maintenance Suggested Cleaning Materials: Moving and Storage Troubleshooting REPRESENTATIVE ILLUSTRATION Cleaning and Maintenance Orifices For Your Additional Safety Troubleshooting Regulator Nipple with Excess Flow Valve IMPORTANT! WICHITA ,KS 67201 PO BOX 2931 ATTN: DEPT 586 Coleman Grill Warranty Registration Card CONGRATULATIONS ON YOUR NEW COLEMAN GRILL PURCHASE! Number of kids in household under 18 years of age: 18 Which best describes your family income? 13 2. Mrs. 3. Ms. 4. Miss. Page Page Page Coleman Gas Barbecue Grill Limited Warranty Warranty