Country Home Products Garden Cart operating instructions About the Overload Safety Feature

•Pull the battery partially out of the unit to access the wire terminals. from the battery terminals by unscrewing the terminal nut and bolt. adjustable wrench.

Disconnect the red and the black wires Use a Phillips screwdriver and an

•Slide the old battery the rest of the way out of the unit and slide the new battery in its place.. The color coded battery terminals are positioned outward for easy access. Reconnect the wire terminals to the new battery.. The red wire connects to the red marked battery terminal and the black wire connects to the black marked battery terminal. Use a Phillips screwdriver and an adjustable wrench to securely tighten the terminal hardware.

•Slide the new battery fully back into the unit. Tuck the wires around the battery so they are not in the way of the battery door.

•Align the battery door with the square block (on the inside of the battery door) towards the battery and face the screw holes down. Slightly angle the tab on the battery door on the drive train’s lip (in the battery opening) and hook it on (Figure 10).

•Make sure the battery wires don’t stick out from under the door.

•Reattach the screws though each hole in the battery door, and tighten them snugly with a Phillips screwdriver. Be careful not to over-tighten them.

•Tilt the unit back onto its wheels. Run the unit briefly to check that the battery replacement went well.

About the Overload Safety Feature

Your NEUTON Garden Cart has a built-in safety fuse. If your Cart is overloaded or the operating conditions are too severe, the safety fuse automatically trips and stops your Cart. The fuse automatically resets itself after about 5 seconds. Then you can move your Cart again.

Of course, before you use your Cart again, you should change how you are using your Cart. Try reducing the load. Keep under 200 pounds (90 kilograms) on level surfaces; no more than 175 pounds (79 kilograms) on a 10° slope; and no more than 150 pounds (68 kilograms) on a 20° slope.

Don’t drive straight up slopes; move up and down a slope at less of an angle. Keep out of loose or muddy terrain, which can cause the wheels to spin freely or even stop spinning while power is still being supplied to the motor; drive on more solid ground.

All these tips help keep the fuse from shutting down.

If the fuse continually trips while you are using your Cart under normal conditions, please contact our Technical Support Department at 1-866-NEUTON1(638-8661).

BE CAREFUL WHEN YOU ARE MOVING UP A STEEP INCLINE OR USING THE CART IN SEVERE CONDITIONS. IF THE SAFETY FUSE DOES TRIP, THE CART’S LOAD MIGHT SUDDENLY SHIFT AND ALLOW THE CART TO ROLL BACK ON YOU, CAUSING SEVERE INJURY.

CALL TOLL FREE 1-866-NEUTON1 19