Craftsman 580.32727 Service and Adjustments, Storage, Engine Speed, Adjusting the Carburetor

......SERVICE AND ADJUSTMENTS

ENGINE SPEED

CAUTION: ENGINE SPEED WAS PROPERLY AD- JUSTED AT THE FACTORY AND SHOULD RE-

QUIRE NO ADDITIONAL ADJUSTMENT. DO NOT

ATTEMPT TO CHANGE ENGINE SPEED. IF YOU BELIEVE THE ENGINE ISRUNNING TOO FAST OR

TOO SLOW, TAKE YOUR GENERATOR TO AUTHORIZED SERVICE (3ENTER FOR REPAIR AND ADJUSTMENT. CHANGING ENGINE GOV- ERNED SPEED WILLVOIDrENG1NE WARRANTY.

Your generator runs at a constant speed. This constant operating speed is maintained by a mechanical, flyv_ight type, fixed speed governor._ DO NOT try to adjust the governed speed setlJngfor the following reasons:

•High engine speeds are dangerous and increase the risk of personal injury or damage to equipment,

•Lowengine speeds impose a heavy load on the engine when sufficient engine power is not available and may shorten engine life.

oThe generator will supply correct rated AC frequenm¢ and voltage onlyatthe proper speed. Some connected electrical devices could be damaged by incorrect fre- que ncy andior voltage.

ADJUSTING THE CARBURETOR

The carburetor of your generator set is preset atthe factory. DO NOT TAMPER WITH THE CARBURETOR as this will

void the warranty for the emission con_'olsystem. If your generator is to be used at an altitude above 5,000 feet, consult with a Sears Authorized Service Facility regarding high altitude jet_ng changes.

STORAGE

The generator should be stared at least once every seven days and allowad to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30days, use me following information as a guide to prepare it for

storage.

STORAG E INSTR UCTIONS

WARNING: NEVER STORE ENGINE WITH FUEL tN

THE TANK INDOORS OR IN ENCLOSED, POORLY

VENTILATED AREAS, WHERE FUMES CAN REACH AN OPEN FLAME SPARK OR PILOT LIGHT

AS ON A FURNACE, WATER HEATER, CLOTHES DRYER OR OTHER GAS FURNACE,

ENGINE

•Run engine for about five minutes to warm it.

NOTE: lfyou did use "gasohol," drain fuel tank, then run engine until engine stops from lack of fuel.

Ait TAINER OUTDOORS, AWAY FROM OPEN FLAME.

I A WARNING: DRAIN FUEL INTO APPROVED CON- BE SURE ENGINE IS COOL.

®

NOTE: Using a fuel additive such as Sears Craftsman Fuel Stabilizer, or an equivalent, will prevent gum deposits from forming in _e generator's fiJel system.

oWhile engine is still warm° drain oil from crankcase. Refill with fresh oil. See BEFORE STARTING EN- GINE on Page 5 for oil recommendations.

•Remove spark plug and pour about I ounce (30ml) of engine oil into cylinder, Crank slov_y to distIibute oil.

CAUTION: AVOID SPRAY FROM SPARK PLUG HOLE WHEN CRANKING ENGINE SLOWLY.

•Install spark plug. Do not connect spark plug wire.

oClean dirt, oil and grease from cylinder, cylinder head, fins, blower housing, rotating screen and muffler area.

GE NE RATOR

=Clean the generator as outlined on Page 7 (_Fo Clean the Generator').

•Check that cooling air slots and openings on generator are open and unobstructed.

OTHER STORAGE TIPS

•DO not store gasoline from one season to another.

eReplace your gasoline can if it starts to rust. Rust and/or dirt in your gasoline can cause problems when you use it with this unit.

o Store in clean and dry area.

DANGER; STORAGE COVER IS FLAMMABLE. DO NOT PLACE THE STORAGE COVER OVER A HOT GENERATOR. LETTHE UNIT COOL FOR A SUFFI- CIENT TIME BEFORE PLACING THE COVER ON

THE UNIT. tF YOU PLACE THE COVER ON THE

UN1T BEFOREGENERATOR ISCOOL,THE COVER COULD START ON FIRE.

9