TROUBLESHOOTING CHART:
See appropriate section in manual unless directed to Sears service center
PROBLEM | CAUSE | |
Poor grass | 3. | Wet grass• |
discharge |
|
|
(continued) | 4. | Mower deck not level. |
5.Low/uneven tire air pressure.
6.Worn, bent or loose blade.
7.Buildup of grass, leaves and trash under mower.
8.Mower drive belt worn.
9.Blades improperly installed.
10.Improper blades used.
11• Clogged mower deck vent holes from buildup of grass,
leaves, and trash around mandrels.
CORRECTION
3.Allow grass to dry before mowing.
4.Level mower deck.
5.Check tires for proper air pressure.
6.Replace/sharpen blade. Tighten blade bolt.
7.Clean underside of mower housing.
8.Replace mower drive belt.
9.Reinstall blades sharp edge down.
10.Replace with blades listed in this manual.
11.Clean around mandrels to open vent holes.
Headlight(s) not working
(if so equipped)
Battery will not charge
Loss of drive
Engine "backfires" when turning engine "OFF"
1. Switch is "OFF". | 1. Turn switch "ON". |
2.Bulb(s) or lamp(s) burned out. 2. Replace bulb(s) or lamp(s).
3. | Faulty | light | switch. |
| 3. | Check/replace | light switch. | |||||
4. | Loose | or damaged | wiring. | 4. | Check | wiring | and | connections. | ||||
5. | Blown | fuse. |
|
|
| 5. | Replace | fuse. |
| |||
1. | Bad | battery | cell(s). |
| 1. | Replace | battery. |
| ||||
2. | Poor | cable | connections. | 2. | Check/clean | all | connections. | |||||
3. | Faulty | regulator |
|
| 3. | Replace | regulator. | |||||
| (if so | equipped). |
|
|
|
|
|
|
|
| ||
4. | Faulty | alternator. |
|
| 4. | Replace | alternator. | |||||
1. | Freewheel | control |
| in | 1. | Place | freewheel | control in | ||||
| "disengaged" | position. |
| "engaged" |
| position. | ||||||
2. | Motion | drive belt | worn, | 2. | Replace | motion | drive belt. | |||||
| damaged, | or broken. |
|
|
|
|
|
| ||||
3. | Air | trapped | in transmission | 3. | Purge | transmission. | ||||||
| during | shipment | or | servicing. |
|
|
|
|
|
|
•Engine throttle control not set • Move throttle control
between half | and full | speed | between | half | and full speed |
(fast) position | before | stopping | (fast) position | before | |
engine. |
|
| stopping | engine. |
30