Crown Boiler 32 BASE SIDE CARTON

63

61

"A" "B" "C" "D" "E"

7" PUSHNIPPLE 310005 5 6 7 8 9

3" PUSHNIPPLE 310006 5 6 7 8 9

5/8 X 9 3/4 TIE ROD 900310 15 18 21 24 27

5/8 HEX NUT 900311 30 36 42 48 54

5/8 FLAT WASHER 900312 30 36 42 48 54

LOCTITE # 592, 50 ml TUBE 900350 2 3 3

LOCTITE # 592, 250 ml TUBE 900355 1 1

"SECTION SEAL", 1 QUART CAN 900360 2 2 2 2 2

WOOD WEDGE 970030 2 2 2 2 2

SECTION JOINER CARTON

PART # QUANTITY

DESCRIPTION

RH BASE SIDE PANEL ASSY. 310662 1

LH BASE SIDE PANEL ASSY. 3 10663 1

JAC KET SI DE PANEL ZEE B RAC KET 310 302 2

JAC KET TO P SUPPORT BRA CKET 310 320 1

JAC KET TO P SUPPORT END A NGLE 31 032 1 2

JACKET REA R PANEL SUPPORT BRA CKET 31 0310 1

REAR TIE ROD CHANNEL BRA CKET 3103 11 1

5/8 X 4 STUD 900309 1

5/8 USS WASHER 900312 2

5/8 NUT 900311 2

3/8-16 X 3/4 CAP SCREW 90-035 4

3/8 USS FLAT WASHER 90-036 4

3/8-16 HEX NUT 90-221 8

BLOCK A NCHOR 310010 4

3/8-16 X 2 CAP SCREW 900455 4

#10 X 1/2 HEX HD SHEET METAL SCREW 90-212 20

BASE SIDE CARTON

PART # QTY .DESCRIPTION

RH JACKET SIDE PANEL ASSY . 31030 0 1

LH JACKET SIDE PANEL ASSY. 310301 1

JACKET SIDE P ANEL CARTON

PART #DESCRIPTION QTY.

Contents

Main D E S I G N E D T O L E A D Series 32 Gas-Fired Natural Draft Steam or Water Boilers INSTALLATION AND OPERATING INSTRUCTIONS These instructions must be affixed on or adjacent to the boiler. Page Table of Contents I Product Description Page Table 1A: Dimensional Data 1. All Dimensions Are Approximate. Table 1B: Specifications Page Page III Before Installing IV Locating the Boiler Table 2: Minimum Room Volumes Based On Sixteen Times Boiler Volume By Model Size Figure 3: Clearances To Combustible Construction Table 3: Minimum Clearances to Combustibles V Knockdown Boiler Assembly Instructions B. Base Assembly Page C. Section Assembly Page Page Page Page D. Jacket Assembly Instructions Figure 13: Jacket Mounting Bracket Arrangement Page VI Air For Combustion and Ventilation Warning Figure 15: Boiler Installed In Confined Space, All Air From Inside Page Page VII Venting Table 4: Sizing For Vent Systems Outside The Scope Of The National Fuel Gas Code Venting Tables Page Removing An Existing Boiler From A Common Chimney VIII Steam Boiler Piping & Trim Installation A. Heating System Piping (Steam Boilers) DANGER Table 5 Figure 22: Steam Boiler Tapping Locations Tapping Uses Chart For Steam Boilers Page Figure 25: Common Near-Boiler Piping Mistakes Table 6: Steam Boiler Riser & Header Pipe Sizes Page Page Page Page B. Indirect Water Heating Piping (Steam Boilers) IX Water Boiler Piping A. Heating System Piping DANGER Tapping Uses Chart For Water Boilers Figure 29: Water Boiler Tapping Locations Table 7 Page Table 8: Water Boiler Supply & Return Pipe Sizes Figure 31: Recommended Boiler Piping For Combination Heating & Cooling Systems B. TANKLESS HEATER PIPING 43 Table 9: Tankless Heater Specifications Figure 32: Tankless Heater Piping X Gas Piping XI Control System Wiring Sequence of Operation CSD-1 Boiler Wiring Figure 34: Typical Wire Routing Page Page Safety Control Operation XII Start-up and Checkout Figure 37: Pilot Burner Flame Figure 38: Main Burner Flame Page Page OPERATING INSTRUCTIONS TO TURN OFF GAS TO APPLIANCE FOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONS FOR BASE MODULES EQUIPPED WITH HONEYWELL VR8304 SERIES GAS VALVES OPERATING INSTRUCTIONS TO TURN OFF GAS TO APPLIANCE FOR YOUR SAFETY READ BEFORE LIGHTING GAS INLET GAS CONTROL KNOB SHOW N IN "OFF" P OSITION POSITION INDICATOR XIII Service and Maintenance Page XIV PARTS SERIES 32 MASTER PARTS LIST BASE CARTON MODEL T-1 T-2 T-3 310022 TANKLESS CO ILS PARTS PART # 310020 310021 INTERMEDIATE CARTON SECTION JOINER CARTON BASE SIDE CARTON JACKET SIDE P ANEL CARTON BASE PARTS Page BASE PARTS (CONTD.) Page WATER TRIM CARTON STEAM TRIM CARTON WATER BOILER CARTON STEAM BOILER CARTON