Manuals / Dixon / Lawn and Garden / Lawn Mower

Dixon 4500 Series manual Specifications, Models ZTR 4515Band4515K

Models: 4500 Series

1 39

Download 39 pages 6.66 Kb

Page 11

SPECIFICATIONS

	SPECIFICATIONS
	Models ZTR 4515Band4515K
CHASSIS:	Twin 12 gauge side frames and 7 gauge transmission and engine base plate.
BODY:	All body parts are made of high density polyethylene. Dent and corrosion
	resistant. Front body contains access panel for battery service.
MOWER DECKS:	36" Deck: 1 1 GA Laser Cut Fabricated - 36" Cut Width 42"
	Deck: 13 GA Stamped Steel Construction - 42" Cut Width
	Cut height approximately 1 " to 4" via 7 position lift handle.
BLADE DRIVE:	Electric clutch.
TRANSMISSION:	Each rear wheel is independently driven by a HydroGear IZT hydrostatic drive.
ENGINE:
Model 451 5B:	15 HP Vanguard Briggs & Stratton, 4-Cycle, Single Cylinder, Overhead
	Valve, Air-Cooled, Gasoline, Vertical Shaft With Cast Iron Cylinder
	Sleeve, Oil Pump With Integral Oil Filter.
Model 451 5K:	15 HP Kohler Command 15, 4-Cycle, Single Cylinder, Overhead Valve,
	Air-Cooled, Gasoline, Pressure Lubricated, With Oil Filter, Vertical Shaft,
	Aluminum Head and Block with Cast-Iron Cylinder Liner.

STARTING SYSTEM:

TIRES:

RECOMMENDED TIRE PRESSURE:

CAPACITIES:

Electric by key switch operation with safety interlock blade drive.

Front	1 1 X 4.00 X 5 ribbed tread.
Rear	1 8 X 8.50 X 8 Multi-Trac
Front	16-21 Ibs.
Rear	8-1 4 Ibs.
Fuel	2.7 gallons total. Engine	Briggs

&Stratton - 1 .50 quarts oil. Kohler - 2 quarts oil with filter.

DIMENSIONS:	Width	44" Maximum Track Width
	Height	42" to top edge of seat. Length
	72" hitch tab to front bumper. Weight
	Power Unit: 463 Ibs. w/36" Deck:
	544 Ibs. w/42" Deck: 541 Ibs.
NOTE:	Additional information provided in service instructions under the individual component.

SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE

Page 8

Image 11

Dixon 4500 Series manual Specifications, Models ZTR 4515Band4515K

Contents

Page IMPORTANT READ CAREFULLY SPECIFICATIONS INDEXSAFETY WARRANTY POLICYPage The most common causes of injury to the operator or bystanderread and understand this manual to prevent injuries Follow recommended safety precautions and safe operating practices SAFETYSAFETY SYMBOLS GENERAL OPERATION serious injury or deathDO NOT All slopes require extra caution. If you cannot back upthe slope or if you feel uneasy on it, do not mow it SLOPE OPERATIONpresence of children NEVER assume children will stay where they were last seenCHILDREN Tragic accidents can occur if the operator is not alert to theSERVICE b Routine maintenance or adjustments DIXON PROTECTION PLUS TWO YEAR LIMITED WARRANTY POLICY4. Battery warranty Limited to 90 days from date of purchase 7. The following items are not covered by this warranty policyModels ZTR 4515Band4515K SPECIFICATIONSPage SEAT ADJUSTMENT INSTRUCTIONS Models ZTR 4515B & ZTR 4515KDO NOT operate mower without seat adjustments properly tightened Page CONTROLSModels ZTR 4515B and4515K TO SET PARKING BRAKE CONTROLSAll controls are described from operators position PARKING BRAKETURNING CONTROLSTO GO FORWARD TO GO BACKWARDProtection of the electrical system is by 115 amp circuit breaker CONTROLSOPERATION INSTRUCTIONS Engine should not turn over or attempt to start TESTING OF SAFETY INTERLOCK SYSTEMSOPERATION INSTRUCTIONS Engine should not turn over or attempt to startPage OPERATION INSTRUCTIONSEngage parking brake before starting engine STARTING INSTRUCTIONSMOWING WITH A MULCHING ATTACHMENT OPERATION INSTRUCTIONSMOWING WITH A GRASS CATCHER ATTACHMENT OPERATION INSTRUCTIONSGRASS HEIGHT SUGGESTIONS Be sure that deflector is properly installed on the discharge chuteOPERATION INSTRUCTIONS SIDE DISCHARGE OF THE CLIPPINGSMAINTENANCE SCHEDULE CARE AND MAINTENANCEBefore performing any maintenance, shut off engine, allowto cool Page CARE AND MAINTENANCEMOWER BLADE MAINTENANCE BELT TENSION CARE AND MAINTENANCEPage Page CARE AND MAINTENANCEFORWARD TRAVEL SPEED ADJUSTMENT Page CARE AND MAINTENANCENEUTRAL ADJUSTMENT MOWER DECK LEVELING PROCEDURE CARE AND MAINTENANCE36 DECK REMOVAL CARE AND MAINTENANCE42 DECK REMOVAL CARE AND MAINTENANCEPage CHANGING THE ENGINE OIL CARE AND MAINTENANCESERVICE INTERVALS OIL FILLLUBRICATION CARE AND MAINTENANCEThe serial number is located on frame at rear of engine, it will CARE AND MAINTENANCEKeep all connections clean and tight See your Dixon dealer for replacement parts, warranty orBRIGGS & STRATTON FILTER PART NUMBERS STANDARD SERVICE PARTS LIST36 DECK 42 DECKCAUSES TROUBLESHOOTINGMOWER CUT QUALITY SITUATIONadjustment Neutral adjustmentRefer to page 24 for procedure or Refer to page 23 for procedureELECTRICAL SYSTEM TROUBLESHOOTINGHave electrical system checked by your increase engine RPM Contact yourDATE ENGINE TUNED OWNER INFORMATIONDATE PURCHASED MOWER MODEL NUMBER MOWER SERIAL NUMBER PURCHASED FROM DATE OIL CHANGED4500 Series Part No Dixon and ZTR are registered trademarks of Dixon Industries, Inc