Manuals / Dixon / Lawn and Garden / Lawn Mower

Dixon 4500 Series manual Care And Maintenance, Page, Deck Removal

Models: 4500 Series

1 39

Download 39 pages 6.66 Kb

Page 30

Image 30

CARE AND MAINTENANCE

42" DECK REMOVAL:

1.Place cut height lever in lowest cut position.

2.Pull belt idler back to allow belt to be removed from idler pulley and electric clutch pulley.

3.Remove hair pin cotter and washer from one end of deck support cross shaft. Note location of remaining shim washers used between chassis and mower deck plates. Slide shaft from chassis and mower deck.

4.Remove hair pin cotter and washer from each deck L-rod. Remove L-rods from lift arms. At this point, deck will drop down.

5.Carefully raise and support front of chassis. Slide mower deck to either side for removal. (Reverse procedure to reinstall deck assembly).

NOTE: When deck is reinstalled on frame, check that belt is correctly routed in the groves of all pulleys and that belt idler is applying tension to the back side of the belt.

Page 27

Page 30

Image 30

Dixon 4500 Series manual Care And Maintenance, Page, Deck Removal

Contents

Page IMPORTANT READ CAREFULLY WARRANTY POLICY INDEXSAFETY SPECIFICATIONSThe most common causes of injury to the operator or bystander read and understand this manual to prevent injuriesPage SAFETY SAFETY SYMBOLSFollow recommended safety precautions and safe operating practices serious injury or death GENERAL OPERATIONSLOPE OPERATION All slopes require extra caution. If you cannot back upthe slope or if you feel uneasy on it, do not mow it DO NOTTragic accidents can occur if the operator is not alert to the NEVER assume children will stay where they were last seenCHILDREN presence of childrenSERVICE 7. The following items are not covered by this warranty policy DIXON PROTECTION PLUS TWO YEAR LIMITED WARRANTY POLICY4. Battery warranty Limited to 90 days from date of purchase b Routine maintenance or adjustmentsSPECIFICATIONS Models ZTR 4515Band4515KSEAT ADJUSTMENT INSTRUCTIONS Models ZTR 4515B & ZTR 4515K DO NOT operate mower without seat adjustments properly tightenedPage CONTROLS Models ZTR 4515B and4515KPage PARKING BRAKE CONTROLSAll controls are described from operators position TO SET PARKING BRAKETO GO BACKWARD CONTROLSTO GO FORWARD TURNINGCONTROLS Protection of the electrical system is by 115 amp circuit breakerOPERATION INSTRUCTIONS Engine should not turn over or attempt to start TESTING OF SAFETY INTERLOCK SYSTEMSOPERATION INSTRUCTIONS Engine should not turn over or attempt to startSTARTING INSTRUCTIONS OPERATION INSTRUCTIONSEngage parking brake before starting engine PageOPERATION INSTRUCTIONS MOWING WITH A MULCHING ATTACHMENTOPERATION INSTRUCTIONS MOWING WITH A GRASS CATCHER ATTACHMENTSIDE DISCHARGE OF THE CLIPPINGS Be sure that deflector is properly installed on the discharge chuteOPERATION INSTRUCTIONS GRASS HEIGHT SUGGESTIONSCARE AND MAINTENANCE Before performing any maintenance, shut off engine, allowto coolMAINTENANCE SCHEDULE CARE AND MAINTENANCE MOWER BLADE MAINTENANCEPage CARE AND MAINTENANCE PageBELT TENSION CARE AND MAINTENANCE FORWARD TRAVEL SPEED ADJUSTMENTPage CARE AND MAINTENANCE NEUTRAL ADJUSTMENTPage CARE AND MAINTENANCE MOWER DECK LEVELING PROCEDURECARE AND MAINTENANCE 36 DECK REMOVALCARE AND MAINTENANCE Page42 DECK REMOVAL CARE AND MAINTENANCE CHANGING THE ENGINE OILCARE AND MAINTENANCE OIL FILLLUBRICATION SERVICE INTERVALSSee your Dixon dealer for replacement parts, warranty or CARE AND MAINTENANCEKeep all connections clean and tight The serial number is located on frame at rear of engine, it will42 DECK STANDARD SERVICE PARTS LIST36 DECK BRIGGS & STRATTON FILTER PART NUMBERSSITUATION TROUBLESHOOTINGMOWER CUT QUALITY CAUSESRefer to page 23 for procedure Neutral adjustmentRefer to page 24 for procedure or adjustmentincrease engine RPM Contact your TROUBLESHOOTINGHave electrical system checked by your ELECTRICAL SYSTEMDATE OIL CHANGED OWNER INFORMATIONDATE PURCHASED MOWER MODEL NUMBER MOWER SERIAL NUMBER PURCHASED FROM DATE ENGINE TUNEDDixon and ZTR are registered trademarks of Dixon Industries, Inc 4500 Series Part No