Manuals / Dixon / Lawn and Garden / Lawn Mower

Dixon 4500 Series Troubleshooting, Have electrical system checked by your, Electrical System

Models: 4500 Series

1 39

Download 39 pages 6.66 Kb

Page 37

Image 37

TROUBLESHOOTING

ELECTRICAL SYSTEM:

SITUATION	CAUSES	REMEDY
Starter will not	Circuit breaker	Push button to reset Consult
turn engine over	disengaged	your dealer for repair

Starter will not	Dead battery	Charge battery
turn engine over

Battery discharge	Poor connections on	Tighten or replace as required
	battery	i
	battery
	Battery water low
	Wrong battery installed
	in mower

Battery discharge	Engine electrical system	Have electrical system checked by your
	not functioning correctly	dealer

Battery discharge	Engine not being	increase engine RPM Contact your
	operated at full throttle	dealer for information

NOTE: Electrical system failures are generally simple in nature, always check the obvious first and then move onto the more complicated parts used.

Poor battery service, loose connections, corrosion, frayed or broken wiring, are more likely than component failure.

Page 34

Page 37

Image 37

Dixon 4500 Series manual Troubleshooting, Have electrical system checked by your, increase engine RPM Contact your

Contents

Page IMPORTANT READ CAREFULLY SAFETY INDEXWARRANTY POLICY SPECIFICATIONSread and understand this manual to prevent injuries The most common causes of injury to the operator or bystanderPage SAFETY SYMBOLS SAFETYFollow recommended safety precautions and safe operating practices GENERAL OPERATION serious injury or deaththe slope or if you feel uneasy on it, do not mow it All slopes require extra caution. If you cannot back upSLOPE OPERATION DO NOTCHILDREN NEVER assume children will stay where they were last seenTragic accidents can occur if the operator is not alert to the presence of childrenSERVICE 4. Battery warranty Limited to 90 days from date of purchase DIXON PROTECTION PLUS TWO YEAR LIMITED WARRANTY POLICY7. The following items are not covered by this warranty policy b Routine maintenance or adjustmentsModels ZTR 4515Band4515K SPECIFICATIONSDO NOT operate mower without seat adjustments properly tightened SEAT ADJUSTMENT INSTRUCTIONS Models ZTR 4515B & ZTR 4515KPage Models ZTR 4515B and4515K CONTROLSPage All controls are described from operators position CONTROLSPARKING BRAKE TO SET PARKING BRAKETO GO FORWARD CONTROLSTO GO BACKWARD TURNINGProtection of the electrical system is by 115 amp circuit breaker CONTROLSOPERATION INSTRUCTIONS OPERATION INSTRUCTIONS TESTING OF SAFETY INTERLOCK SYSTEMSEngine should not turn over or attempt to start Engine should not turn over or attempt to startEngage parking brake before starting engine OPERATION INSTRUCTIONSSTARTING INSTRUCTIONS PageMOWING WITH A MULCHING ATTACHMENT OPERATION INSTRUCTIONSMOWING WITH A GRASS CATCHER ATTACHMENT OPERATION INSTRUCTIONSOPERATION INSTRUCTIONS Be sure that deflector is properly installed on the discharge chuteSIDE DISCHARGE OF THE CLIPPINGS GRASS HEIGHT SUGGESTIONSBefore performing any maintenance, shut off engine, allowto cool CARE AND MAINTENANCEMAINTENANCE SCHEDULE MOWER BLADE MAINTENANCE CARE AND MAINTENANCEPage Page CARE AND MAINTENANCEBELT TENSION FORWARD TRAVEL SPEED ADJUSTMENT CARE AND MAINTENANCEPage NEUTRAL ADJUSTMENT CARE AND MAINTENANCEPage MOWER DECK LEVELING PROCEDURE CARE AND MAINTENANCE36 DECK REMOVAL CARE AND MAINTENANCEPage CARE AND MAINTENANCE42 DECK REMOVAL CHANGING THE ENGINE OIL CARE AND MAINTENANCELUBRICATION OIL FILLCARE AND MAINTENANCE SERVICE INTERVALSKeep all connections clean and tight CARE AND MAINTENANCESee your Dixon dealer for replacement parts, warranty or The serial number is located on frame at rear of engine, it will36 DECK STANDARD SERVICE PARTS LIST42 DECK BRIGGS & STRATTON FILTER PART NUMBERSMOWER CUT QUALITY TROUBLESHOOTINGSITUATION CAUSESRefer to page 24 for procedure or Neutral adjustmentRefer to page 23 for procedure adjustmentHave electrical system checked by your TROUBLESHOOTINGincrease engine RPM Contact your ELECTRICAL SYSTEMDATE PURCHASED MOWER MODEL NUMBER MOWER SERIAL NUMBER PURCHASED FROM OWNER INFORMATIONDATE OIL CHANGED DATE ENGINE TUNED4500 Series Part No Dixon and ZTR are registered trademarks of Dixon Industries, Inc