MAINTENANCE
Cleaning the Stainless Steel Cook Grate
To keep your grill operating properly, the stainless steel cook grate should be cleaned regularly.
1. The stainless steel cook grate can be easily cleaned after the
The Ducane® stainless steel cook grate has been constructed of strong, sturdy stainless steel. You will find this cooking surface to be extremely durable while providing more heat directly to your cooking surface for faster, more economical cooking.
Cleaning the Heat Distribution Plates
Your stainless steel heat distribution plates should also be brushed down with the use of a brass
Cleaning the Burner Box
Clean when cook grate and heat distribution plates are removed from burner box. Clean out any ash or deposits from burner box using warm soapy water and a soft cloth. Allow to dry before replacing all parts.
A small amount of grease may accumulate on the bottom of the burner box. It can be scraped up and discarded with a
Prolonged grilling with the hood in the down position may cause a grease build up in- side the hood that will begin to flake (this is not paint). If this develops, clean the inside of the hood with a warm water and soap solution. Be careful not to get the burner wet.
Preserve Your Cabinet, Control Panel and Shelf/Shelves
Your cabinet, control panel and shelves are made from stainless steel. To keep the stainless steel looking its best is a simple matter. Clean it with soap and water, rinse with clear water and wipe dry. It’s that easy. We recommend the use of a diluted liquid dishwashing detergent and water solution. For stubborn particles, the use of a
2. For safety reasons. A dirty grill is susceptible to grease fires.
Depending on the amount of cooking, the types of food cooked, the amount of pre- heating and
If a grease fire were to occur on a Ducane® grill, flames would probably be seen under the burner box. A severe grease fire could lead to a burned hose or regulator which would allow gas to feed the fire and, obviously, make the fire worse.
Any type of fire requires that the grill components (hose, regulators, LP tanks, etc...) involved be checked for continued safe operation. If a leak is suspected, the gas supply system (hose, manifold, tank, fittings, etc...) must be leak tested, using a soapy water solution, to verify the source of the leak. If no leak is found, then the problem was most likely a grease fire.
A grease fire can be severe enough to damage your grill and/or cause property damage and/or cause bodily harm. Ducane does not want this to happen and neither do you. Follow our cleaning recommendations to avoid grease fires.
mCAUTION: Do not use a wire brush or abrasive cleaners on the lid, cabinet and shelves of your grill as this will scratch the surface.
mCAUTION: When cleaning surfaces be sure to rub in the direction of the grain to preserve the look of your stainless steel.
Grease Fires
The recommendations in the Maintenance section, concerning cleaning our grill, and in the Normal Operation section concerning preheating and
1.Keep your grill cooking at its best by keeping the cooking surfaces and heat trans- mitting components clean. Keeping your grill clean is the best way of keeping your grill cooking properly.
mWARNING: Check the grease tray for grease
| ANNUAL MAINTENANCE |
|
Inspection and Cleaning of the Spider/Insect Screens |
| |
To inspect the Spider/Insect screens. |
| |
1. | Turn “OFF” gas at source. |
|
2. | Remove the cooking grate and the heat distribution plates, exposing the burner |
|
| tubes. |
|
18 | www.ducane.com | |
