Manuals
/
Exmark
/
Lawn and Garden
/
Lawn Mower
Exmark
COMMERCIAL 21 manual Commercial, For Serial Nos 312,000,000 & Higher
Models:
COMMERCIAL 21
1
1
40
40
Download
40 pages
6.37 Kb
1
2
3
4
5
6
7
8
<
>
Troubleshooting
Specs
Warranty
Maintenance
Problem
Handle Adjustment
Emptying the Fuel Tank and Cleaning the Fuel Filter section
Safety Alert Symbol
How to
Safety
Page 1
Image 1
COMMERCIAL 21
For Serial Nos.
312,000,000 & Higher
Part No.
4500-927
Rev. A
Page 2
Page 1
Image 1
Page 2
Contents
For Serial Nos 312,000,000 & Higher
COMMERCIAL
All Rights Reserved
CALIFORNIA Proposition 65 Warning
Model No Serial No
Introduction
Periodic Maintenance
Contents
Cleaning Under the Cover Plate Non-Blade
Introduction
Safety Alert Symbol
Safety
Safety
ALERT! YOUR SAFETY IS INVOLVED
Avoid prolonged breathing of vapors
DANGER
Keep face away from nozzle and gas tank/container opening
Keep away from eyes and skin Never siphon by mouth
Allow engine parts, especially the muffler, to cool before touching
Operation
Remove accumulated debris from muffler and engine area
Keep hands, feet, hair, jewelry, or clothing away from rotating parts
Do Not mow slopes when grass is wet
Maintenance and Storage
Slope Operation
Mow across slopes, never up and down
Safety
Safety and Instructional Decals
109-9317 116-1922
Safety
Dimensions
Specifications
Specifications
Safety Interlock System
Product Overview
Product Overview
Overall Length and Height at 2 1/2 inch Cutting Height
Operation
Engine Stop Switch
Controls
Operation
Fuel Shut-Off Valve
Pre-Start
Operation
Operating Instructions
Handle Adjustment
Open the Fuel Shut-Off Valve
Starting the Engine
Operating the Self-Propel Drive Self-Propelled Units Only
Stopping the Engine
Operating the Blade Control Bail Units Without Blade Brake Clutch
Operating the Blade Control Lever Blade Brake Clutch Units Only
Checking the Blade Brake Clutch Blade Brake Clutch Units Only
Using the Mulch Plug
Operation
Adjusting the Cutting Height
Test Using the Grass Bag
Authorized Service Dealer
Rear Wheel Adjustment
Operation
Using the Grass Bag
Cut the grass until the bag is full. Note Do Not overfill the bag
Operation
Operating Tips
DANGER
Recommended Maintenance Schedules
Maintenance
Maintenance
Service Interval Before each use or daily
Periodic Maintenance
Check Engine Oil Level
Checking the Blade Brake Clutch Blade Brake Clutch Only
Inspect the blade periodically for wear or damage
Emptying the Fuel Tank and Cleaning the Fuel Filter section
Replace a worn or damaged blade
Maintenance
Check the Blade Brake Clutch Bail Operation Blade
Check for Loose Hardware
Brake Clutch Units Only
Maintenance
Service Air Filter ECXHNBBC21 and ECXHN21 Units
Service Air Filter Kawasaki Units
Maintenance
Every 250 hours- Replace the air filter elements
Avoid contacting the hot engine oil when you drain it
Service Interval After the first 5 hours
Change Engine Oil
Every 50 hours May need more often under severe conditions
Service Interval Every 40 hours
Service Interval Every 100 hours
Change Oil Filter ECXKA21 and ECXKABBC21
Check Condition Of Belt Self-Propelled Units Only
Emptying the Fuel Tank and Cleaning the Fuel Filter
Adjustments
Adjusting the Self-Propel Drive Self-Propelled Units Only
Do Not operate the unit when cover is not in place
Maintenance
Adjusting the Blade Brake Cable Blade Brake Clutch Units Only
1. Adjustment of drive cable nuts
1. Spring
Clean Grass Build-Up Under Deck
Cleaning
Cleaning the Discharge Tunnel and Plug
Cleaning Under the Belt Cover Self-Propelled Units Only
Cleaning Under the Cover Plate Non-Blade Brake Clutch Units Only
Cleaning the Blade Brake Clutch Shield Blade Brake Clutch Units Only
Maintenance
Service Interval Every 50 hours
Motor Oil Disposal
Waste Disposal
Maintenance
Preparing the Fuel System
Storage
Preparing the Engine
General Storage Information
Troubleshooting
Troubleshooting
Problem
Troubleshooting
Possible Cause
Corrective Action
1 Year Limited Warranty
Exmark Commercial Equipment
Instructions for Obtaining Warranty Service
Owner’s Responsibilities
Page
Service Done By
Service Record
Date
Description of Work Done
Page
MID-MOUNT RIDING ACCESSORIES AND OPTIONS
SEE EXMARK’S COMPLETE LINE OF ACCESSORIES AND OPTIONS
OUT-FRONT RIDING ACCESSORIES AND OPTIONS
WALK-BEHIND ACCESSORIES AND OPTIONS