Generac 005818-0 Appendix

Appendix

MAIN MENU

RUN LOGALARM LOG

HISTORY STATUS

COMMANDSTATE VERSIONSDISPLAY

GENERATOR

FREQUENCY

ENGINE

HOURS

ENGINE

RPM

BATTERY

VOLTAGE

DEBUG

INPUTS OUTPUTS DISPLAYS

EDIT

CONTRAST

LANGUAGE

TIME/DATE

EXERCISE

TIME/SPEED

ESC Press the “ESCAPE” key

to jump back up through

the menu levels.

+ / - Use the “+/-” key

to navigate through

the menu.

ENTER Use the “ENTER” key

to select items or

enter data.

ESC

ESC ESC

Password is entered

on this page.

RESET

MAINTENANCE

QT TEST

HOURS UNDER

LOAD

Contents

Main EcoGen 6kW Generator Owner's Manual Model 005818-0 Table of Contents INTRODUCTION n READ THIS MANUAL THOROUGHLY Data Label Sample SAFETY RULES CONTENTS n n GENERAL HAZARDS EXHAUST HAZARDS ELECTRICAL HAZARDS FIRE HAZARDS EXPLOSION HAZARDS STANDARDS INDEX n 1.1 UNPACKING/INSPECTION 1.2 PROTECTION SYSTEMS 1.3 EMISSION INFORMATION 1.4 THE GENERATOR Figure 1.1 * 6kW, V-twin, GT-530 Engine (door removed) Figure 1.2 * Data Label Sample 1.5 SPECIFICATIONS 1.5.1 GENERATOR n 1.8 FUEL CONSUMPTION 1.9 LOCATION 1.9.1 GENERATOR Figure 1.3 + Generator Clearances 1.9.2 NEW INSTALLATION GUIDELINES FOR STATIONARY AIR-COOLED GENERATORS Figure 1.4 + Installation Guidelines 1.10 BATTERY REQUIREMENTS n n n 1.11 BATTERY INSTALLATION Figure 1.5 + Battery Cable Connections 1.12 THE BATTERY Post Installation Start-up and Adjustments n 1.13 BATTERY CHARGER 2.1 ACTIVATE THE GENERATOR 2.2 BEFORE INITIAL START-UP 2.3 ELECTRICAL CHECKS Post Installation Start-up and Adjustments ACTIVATION CHART n 2.4 GENERATOR TESTS UNDER LOAD 2.5 CHECKING AUTOMATIC OPERATION 3.1 CONTROL PANEL INTERFACE 3.1.1 USING THE AUTO/OFF/MANUAL SWITCH 3.2 AUTOMATIC OPERATION 3.3 SEQUENCE OF AUTOMATIC OPERATION 3.3.1 REMOTE START ON 3.3.2 CRANKING Choke Operation 3.4 SIDE COMPARTMENT 3.4.1 MAIN CIRCUIT BREAKER Figure 3.2 A Side Compartment Figure 3.3 A Open Side Compartment 3.5 PROTECTION SYSTEMS High Engine Temperature (Shutdown Alarm 7 Auto Reset) Over Crank (Shutdown Alarm) Figure 3. 4 7 Low Oil Pressure and High Temperature Switches Over Speed (Shutdown Alarm) RPM Sense Loss (Shutdown Alarm) n 4.2 CHECKING THE ENGINE OIL LEVEL n Figure 4.1 + Oil Dipstick and Fill Oil Fill Oil Dipstick Oil Drain Hose 4.4 CHANGING THE ENGINE AIR CLEANER Figure 4.3 ? Setting the Spark Plug Gap Figure 4.2 ; Engine Air Cleaner 4.5 SPARK PLUGS 4.6 BATTERY MAINTENANCE n n 4.7 ADJUSTING GT-530 VALVE CLEARANCE Figure 4.4 - Valve Clearance Adjustment 4.8 COOLING SYSTEM Figure 4.5 9 Cooling Vent Locations 4.11.2 RETURN TO SERVICE 4.11.3 ACCESSORIES 4.12 SERVICE SCHEDULE ATTENTION: It is recommended that all service work be performed by the nearest Dealer. Troubleshooting 5.1 TROUBLESHOOTING GUIDE Problem Cause Correction Appendix 6.1 MENU SYSTEM NAVIGATION 6.1.1 CHANGING SETTINGS (EDIT MENU) Appendix + / - ENTER ESC Page Page Page Installation Diagram ECO GEN - TYPICAL OFF-GRID APPLICATION SYSTEM DIAGRAM 28 Generac Power Systems, Inc. 28 28 Page Page Notes MANUFACTURER5S WARRANTY COVERAGE: OWNER'S WARRANTY RESPONSIBILITIES: 1-800-333-1322 EMISSION CONTROL SYSTEM WARRANTY EMISSION RELATED PARTS MAY INCLUDE THE FOLLOWING (IF EQUIPPED): GENERAC POWER SYSTEMS LIMITED WARRANTY FOR "ECO GEN AIR-COOLED AUTOMATIC STANDBY GENERATORS" WARRANTY SCHEDULE GUIDELINES THIS WARRANTY SHALL NOT APPLY TO THE FOLLOWING: