Graco 3A0465C important safety instructions Contents

Contents
Important	3
Spray Precautions	3
Fire & Ventilation Precautions	4
Carbon Monoxide Hazard	4
Detergent Cleaning Precautions	4
Burn Hazard	4
Miscellaneous Safety Precautions	5
Adjustment Precautions	5
Personal Protective Equipment	5
Component Identification	6
Installation & Preparation instructions	7
Attire	7
Setup	7
Engine Fuel Tank	8
Nozzle Review	8
Nozzle Connection	9
Water Supply	9
Unloader	10
Thermal Relief Valve	10
Pre-start Inspection Procedures	10
Operating Instructions	11
Priming The Pump	11
Start-up	12
Cleaning With Detergents	13
Shutdown	13
Storage & Maintenance Instructions	14
Engine	14
Pump	14
Nozzles	14
Quick Couplers	14
Winterizing	15
Troubleshooting	16

Pump Service: 2525 Model Pressure Washers	17
For Outlet Valves	17
For Inlet Valves	17
Servicing Plungers Or Internal Bearings	17
Servicing V-packings	17
Pump Service: 2730 Model Pressure Washers	18
Valves	18
Pumping Section	18
Servicing Plungers	18
Servicing V-packings	18
Pump Service: 3030 And 3540 Model Pressure
Washers	19
Valves	19
Pumping Section	19
Servicing Plungers	19
Servicing V-packings	19
Pressure Washer - Parts 262292- Model 2525DD	20
Pump Assembly - Parts - Series A 24E735 (For Use
With Model 2525DD)	22
Pump Assembly - Parts -Series B 24R713 (For Use
With Model 2525DD)	24
Pressure Washer - Parts 262293- Model 2730DD	26
Pump Assembly - Parts 244749 (For Use With Model
2730DD)	28
Pressure Washer - Parts
262294- Model 3030DD	30
262295- Model 3540DD	30
Pump Assembly - Parts
24E753 (For Use With Model 3030DD)	32
24E750 (For Use With Model 3540DD)	32
Notes	34
Technical Data	35
Graco Standard Warranty	36

The following warnings are for the setup, use, grounding, maintenance, and repair of this equipment. The exclamation point symbol alerts you to a general warning and the hazard symbols refer to procedure-spe- cific risks. When these symbols appear in the body of this manual, refer back to these Warnings. Product- specific hazard symbols and warnings not covered in this section may appear throughout the body of this manual where applicable.

WARNING

important USER INFORMATION

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.

This product contains one or more chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.

The following is required by California State law, Section 4442 of the California Public Resources Code. Other states may have similar laws. Federal laws apply on federal lands.

•A spark arrester must be added to the muffler of this engine if it is to be used on any forest covered, brush covered or grass covered unimproved land. The arrester must be maintained in effective working order by the operator.

•See your engine or equipment dealer for spark arrester muffler options.

spray precautions

Risk of injection or severe cutting injury. If an accident does occur and the spray appears to have pen- etrated the skin, seek emergency medical care. Do not treat as a simple cut. If you are using cleaning agents, be prepared to tell a physician exactly what kind.

•Keep clear of nozzle.

•Do not direct discharge stream at persons or pets.

•Only trained operators should use this product. When operating this unit, basic precautions should always be observed.

•Keep away from the spray. Because of the high pressure and velocity of the spray, fluids can penetrate the skin, causing serious injury.

•Never point the gun at yourself or anyone else. Never put your hand, fingers or body directly over the spray nozzle. Always keep operating area clear of all persons. Use extreme caution when operating near children.

Always wear protective goggles when operating the unit to shield the eyes from flying debris and deter- gents. Other protective equipment such as rubber suits, gloves and respirators are advisable, especially when using cleaning detergents. Use extreme caution when operating near children.

THIS SPARK IGNITION SYSTEM COMPLIES WITH CANADIAN ICES-002.

CE SYSTÈME D’ALLUMAGE PAR ÈTINCELLE EST CONFORME À LA NORME NMB-002 DU CANADA.

2

•Stay alert-watch what you are doing. Do not operate the unit when fatigued or under the influence of alcohol or drugs.

•Never squeeze the trigger unless securely braced. The thrust from the water traveling through the nozzle may be powerful enough to cause the operator to lose balance if unprepared. Do not overreach or stand on unstable support. Wet surfaces can be slippery, wear protective foot gear and keep good footing and balance at all times. Never trigger the gun while on a ladder or roof.

•Caution should be used when directing spray toward fragile materials such as glass. Shattering could result in serious injury.

•Always hold on firmly to the gun/wand assembly when starting and operating the unit. Failure to do so can cause the wand to fall and whip dangerously. Never operate the gun with the trigger wired in the open position. To prevent accidental discharge, the trigger gun should be securely locked when not in use.

3