WARNING
•Do not direct spray on or into electrical installations of any kind! This includes electrical outlets, light bulbs, fuse boxes, transformers, etc. Severe electrical shock may occur.
•Even after you shut off the unit, there is high pressure water left in the pump, hose and gun until you release it by triggering the gun. Before removing the spray nozzle or servicing the unit, always shut off the unit and trigger the gun to release trapped pressure.
Fire & ventilation precautions
•This unit was designed for outdoor use only. Never operate this unit in an enclosed area. Always make certain there is adequate air (oxygen) for combustion as well as ventilation to prevent the presence of poisonous carbon monoxide gases. Beware of poorly ventilated areas or exhaust fans which can cause inadequate combustion or engine overheating.
•Never operate this unit in the presence of flammable vapors or combustible dust, gases or other com- bustible materials. (A spark may cause an explosion or fire.) When servicing this machine, be especial- ly careful to properly dispose of any flammable materials. Do not spray flammable liquids.
•Do not smoke while filling engine fuel tank
•Never fill the engine fuel tank while the unit is running or hot. Allow the engine to cool two minutes before refueling.
•Do not refuel indoors or in a poorly ventilated area.
•Always refuel slowly to avoid the possibility of spilled fuel which may cause a risk of fire.
•Do not operate the unit if gasoline is spilled. Wipe unit clean and move the unit away from the spill. Avoid creating any ignition until the gasoline has evaporated.
•Do not store the unit near an open flame or any equipment such as a stove, furnace, water heater, etc., which utilizes a pilot light or devices which can create a spark.
CARBON MONOXIDE HAZARD
Exhaust contains poisonous carbon monoxide, which is colorless and odorless. Breathing carbon monox- ide can cause death.
• Do not operate in an enclosed area.
Detergent cleaning precautions
•Do not use solvents or highly corrosive detergents or acid type cleaners with this pressure washer.
•Know your detergent. Be prepared to tell a physician exactly what you are using in the event of an emergency. Read the Material Safety Data Sheet (MSDS) provided with your detergent and all deter- gent labels. Follow all appropriate instructions regarding preparation use, safety and transportation.
Keep all detergents out of the reach of children.
•Do not use this pressure washer to dispense hazardous detergents.
•Do not alter the detergent injection feature in any manner not prescribed in this manual. Use only genu- ine replacement parts for necessary repairs.
BURN HAZARD
Equipment surfaces and fluid that’s heated can become very hot during operation. To avoid severe burns:
• Do not touch hot fluid or equipment.
WARNING
miscellaneous safety precautions
Never allow children or adolescents to operate this unit.
Read and follow all handling, operations, maintenance and safety instructions listed in this manual and the engine operator’s manual that accompanies this unit, and provide such information to anyone who will be operating this unit.
In freezing temperatures, the unit must always be warm enough to ensure there is no ice formation in the pump. Do not start this unit if it has been transported in an open or under heated vehicle without first al- lowing the pump to thaw.
When connecting the water inlet to the water supply mains, local regulations of your water company must be observed. In some areas the unit must not be connected directly to the public drinking water supply. This is to ensure that there is no feedback of the detergents into the water supply. (Direct connection is permitted if a back flow preventer is installed.)
Do not allow any part of your body or the high pressure hose to make contact with the muffler. Avoid dragging the hose over an abrasive surface such as cement. This causes wear and eventual rupturing.
High pressure hoses should be inspected daily for signs of wear. If evidence of failure exists, promptly re- place all suspect hoses to prevent the possibility of injury from the high pressure spray. If a hose or fitting is leaking , never place your hand directly on the leak.
Do not operate the unit without all protective covers in place.
Never run the unit with the governor disconnected or operate at excessive speeds.
To reduce the risk of injury, maintain a safe distance for persons while operating this unit. Close supervi- sion is necessary when operating the unit near children.
Do not leave pressurized unit unattended. Shut off the unit and release trapped pressure before leaving.
Do not move the unit by pulling on the hose.
adjustment precautions
•Never alter or modify the equipment, be sure any accessory items and system components being used will withstand the pressure developed. Use only genuine parts for repair of your pressure washer. Fail- ure to do so can cause hazardous operating conditions and will void warranty.
•Never make adjustments to the machinery while it is connected to the engine without first removing the ignition cable from spark plug. Turning the machinery over by hand during adjustment or cleaning might start the engine and machinery with it, causing serious injury to the operator.
•Know how to stop the pressure washer and bleed pressures quickly. Be thoroughly familiar with con- trols.
•Before servicing the unit; turn the unit off, relieve the water pressure, and allow the unit to cool down. Do not make repairs while unit is running. Service in a clean, dry, flat area. Block the wheels to prevent the unit from moving.
•Follow the maintenance instructions specified in this manual.
PERSONAL PROTECTIVE EQUIPMENT
You must wear appropriate protective equipment when operating, servicing, or when in the operating area of the equipment to help protect you from serious injury, including eye injury, hearing loss, inhalation of toxic fumes, and burns. This equipment includes but is not limited to:
•Protective eyewear, and hearing protection.
•Respirators, protective clothing, and gloves as recommended by the detergent manufacturer.
4 | 5 |
