Heat Controller HAH13XX-00-1A K. Condensate Drain, M. Check Test And Start Up, L. Air Filter

K. CONDENSATE DRAIN						M. CHECK TEST AND START UP
						TURN OFF POWER AT BREAKER PANEL
						Electric heaters are high current devices. Verify that
						all electrical connectors, whether push-on or
						compression-type are tight. Loose connections will
						cause the wire and/or terminal to fail.
						The unit should be tested after the system has been
						completely installed to determine proper operation.
						Energize the unit by switching on the line voltage
						source and the thermostat.
The air handler drain pan has ¾” FPT primary and
						N. PERIODIC MAINTENANCE
secondary connections whether used in an upflow or
						Inspect and clean or replace filters at least every three
horizontal configuration. Piping from each stub is to
						months to ensure good airflow and optimum system
have a 1½” minimum trap and each run pitched so as
						capacity, efficiency and life. This equipment should
to provide for adequate drainage and secondary
						NEVER BE RUN WITHOUT AN AIR FILTER in
fittings together into a common drain. When an air
handler is installed above a finished ceiling, an						place (see Section AIR FILTER). The blower motor
auxiliary drain pan must be provided under the unit						is permanently lubricated. ALWAYS disconnect
as required by most				local building codes. The		power before removing access doors!
secondary drain must be piped to a location that
would provide the occupant a warning if the primary
drain is blocked.
L. AIR FILTER									H
Air handlers are factory equipped with an air filter.
If the return grille has its own filter, the filter
installed in the air handler should be removed. Air
filter should be inspected and cleaned or replaced as
often as is necessary to prevent restriction of air flow
(minimum every three months for normal
installations). Always replace the filter with the
same type originally furnished.
					AHB Dimensions24-60
	AHB 24,		0, 3				AHB 42, ,
		HAH 1324, 1336						HAH 1348, 1360

	4 of 6
06/06	HAHIOM062906