Husqvarna 240440 owner manual Engine, Transmission, See Fig

SERVICE AND

REPLACING BATTERY (See Fig. 44)

nals by allowing a wrench or any other

_ objectWARNING:to contactDo notshortboth terminalsbatterytermi=the same time. Before connecting battery, remove metal bracelets, wristwatch

bands, rings, etc. Positive terminal

must be connected first to prevent sparking from accidental grounding.

•Lift hood to raised position.

•Remove terminal cover.

•Disconnect BLACK battery cable then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•Reinstall terminal cover.

•First connect RED battery cable to positive (+) battery terminal with bolt and nut as shown. Tighten securely.

•Connect BLACKgrounding cable to negative (-) battery terminal with remaining bolt and nut. Tighten securely

•Close hood.

NEGATIVE (BLACK)

TERMINAL

ADJUSTMENTS

TO REMOVE HOOD AND GRILL ASSEMBLY

(See Fig. 45)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

		Fig. 45
	ENGINE
POSiTiVE	TO ADJUST THROTTLE		CONTROL	CABLE
(RED)	The throttle control	has been	preset at the	factory and
CABLE
	adjustment should not be necessary. If adjustment is nec-
	essary, see engine	manual.

Fig. 44

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and adjust- ment should not be necessary. If adjustment is necessary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

TRANSMISSION

REMOVAL/REPLACEMENT

Should your transmission require removal for service or replacement, it should be purged after reinstallation and before operating the tractor. See"PU RGETRANSMISSION" in the Operation section of this manual.

25