TROUBLESHOOTING
PROBLEM |
|
| CAUSE |
|
|
|
|
|
|
| CORRECTION |
|
|
|
|
|
|
| |||||
Will | not | start |
| 1. | Out of fuel. |
|
|
| 1. | Fill fuel | tank. |
|
|
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||
|
|
|
| 2. | Engine | not "CHOKED" properly. | 2. | See "TO START ENGINE" | in Operation | section. | |||||||||||||
|
|
|
| 3. | Engine | flooded. |
| 3. | Wait several minutes before attempting | to start. | |||||||||||||
|
|
|
| 4. | Bad spark | plug. |
| 4. | Replace | spark | plug. |
|
|
|
|
| |||||||
|
|
|
| 5. | Dirty | air filter. |
|
| 5. | Clean/replace | air filter. |
|
|
|
|
| |||||||
|
|
|
| 6. | Dirty | fuel | filter. |
|
| 6. | Replace | fuel filter. |
|
|
|
|
| ||||||
|
|
|
| 7. | Water | in fuel. |
|
| 7. | Empty fuel tank and carburetor, | refill | tank with fresh | |||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| gasoline and replace fuel filter. |
|
|
| ||||||
|
|
|
| 8. | Loose | or damaged | wiring. | 8. | Check | all wiring. |
|
|
|
|
| ||||||||
|
|
|
| 9. | Carburetor |
| out of adjustment. | 9. | See "To Adjust | Carburetor" | in Service | Adjustments | |||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| section. |
|
|
|
|
|
|
|
| |
|
|
|
| 10. | Engine valves | out of adjustment. | 10. | Contact | an authorized | service | center/department. | ||||||||||||
Hard | to | start |
| 1. | Dirty air filter. |
|
| 1. | Clean/replace | air filter. |
|
|
|
|
| ||||||||
|
|
|
| 2. | Bad spark | plug. |
| 2. | Replace | spark | plug. |
|
|
|
|
| |||||||
|
|
|
| 3. | Weak |
| or dead | battery. | 3. | Recharge | or replace battery. |
|
|
| |||||||||
|
|
|
| 4. | Dirty | fuel | filter. |
|
| 4. | Replace | fuel filter. |
|
|
|
|
| ||||||
|
|
|
| 5. | Stale | or | dirty fuel. |
| 5. | Empty fuel tank and refill tank with fresh, clean gas. | |||||||||||||
|
|
|
| 6. | Loose | or damaged | wiring. | 6. | Check | all wiring. |
|
|
|
|
| ||||||||
|
|
|
| 7. | Carburetor |
| out of adjustment. | 7. | See "To Adjust | Carburetor" | in Service | Adjustments | |||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| section. |
|
|
|
|
|
|
|
| |
|
|
|
| 8. | Engine valves | out of adjustment. | 8. | Contact | an authorized | service | center/department. | ||||||||||||
Engine | will not |
| 1. | Brake pedal | not depressed. | 1. | Depress | brake | pedal. |
|
|
|
|
| |||||||||
| 2. | Attachment | clutch | is engaged. | 2. | Disengage | attachment | clutch. |
|
|
| ||||||||||||
turn | over |
|
|
|
|
| |||||||||||||||||
|
|
|
| 3. | Weak |
| or dead | battery. | 3. | Recharge | or replace battery. |
|
|
| |||||||||
|
|
|
| 4. | Blown | fuse. |
|
|
| 4. | Replace | fuse. |
|
|
|
|
|
| |||||
|
|
|
| 5. | Corroded |
| battery terminals. | 5. | Clean | battery | terminals. |
|
|
|
| ||||||||
|
|
|
| 6. | Loose | or damaged | wiring. | 6. | Check | all wiring. |
|
|
|
|
| ||||||||
|
|
|
| 7. | Faulty | ignition | switch. | 7. | Check/replace | ignition | switch. |
|
|
| |||||||||
|
|
|
| 8. | Faulty | solenoid | or starter. | 8. | Check/replace | solenoid | or starter. |
|
| ||||||||||
|
|
|
| 9. | Faulty operator presence switch(es). | 9. | Contact | an authorized | service | center/department. | |||||||||||||
Engine | clicks | but | 1. | Weak |
| or dead | battery. | 1. | Recharge | or replace battery. |
|
|
| ||||||||||
2. | Corroded |
| battery terminals. | 2. | Clean | battery | terminals. |
|
|
|
| ||||||||||||
will | not | start |
|
|
|
|
|
| |||||||||||||||
| 3. | Loose | or damaged | wiring. | 3. | Check | all wiring. |
|
|
|
|
| |||||||||||
|
|
|
|
|
|
|
|
| |||||||||||||||
|
|
|
| 4. | Faulty | solenoid | or starter. | 4. | Check/replace | solenoid | or starter. |
|
|
Loss of power
Excessive
vibration
1. | Cutting too much grass/too fast. | 1. | Raise | cutting height/reduce | speed. |
| ||||||||||
2. | Throttle | in "CHOKE" | position. | 2. | Adjust | throttle | control. |
|
|
|
| |||||
3. | of grass, leaves, trash under mower. | 3. | Clean | underside | of mower | housing. |
| |||||||||
4. | Dirty air filter. |
|
|
| 4. | Clean/replace | air filter. |
|
|
|
| |||||
5. | Low oil level/dirty | oil. | 5. | Check | oil level/change | oil. |
|
|
| |||||||
6. | Faulty spark | plug. |
| 6. | Clean and regap or change spark plug. | |||||||||||
7. | Dirty fuel | filter. |
|
| 7. | Replace fuel filter. |
|
|
|
| ||||||
8. | Stale | or | dirty | fuel. |
| 8. | Empty fuel tank and refill tank with fresh, clean gas. | |||||||||
9. | Water | in fuel. |
|
| 9. | Empty | fuel tank and carburetor, | refill | tank with fresh | |||||||
|
|
|
|
|
|
|
|
| gasoline and replace fuel filter. |
|
| |||||
10. | Spark | plug wire | loose. | 10. | Connect and tighten spark | plug | wire. |
| ||||||||
11. | Dirty engine |
| air screen/fins. | 11. | Clean | engine air | screen/fins. |
|
| |||||||
12. | Dirty/clogged | muffler. | 12. | Clean/replace | muffler. |
|
|
|
| |||||||
13. | Loose or damaged | wiring. | 13. | Check | all wiring. |
|
|
|
|
| ||||||
14. | Carburetor | out of adjustment. | 14. | See "To Adjust | Carburetor" | in Service | Adjustments | |||||||||
15. | Engine valves out of adjustment. | 15. | Contact an authorized | service center/department. | ||||||||||||
1. | Worn, | bent | or loose | blade. | 1. | Replace blade. Tighten blade bolt. |
| |||||||||
2. | Bent blade | mandrel. |
| 2. | Replace blade | mandrel. |
|
|
| |||||||
3. | Loose/damaged | part(s). | 3. | Tighten | loose | part(s). | Replace | damaged parts. |
26