Schematic, SCH12 | Husqvarna YTH23V48 guide

TRACTOR - MODEL NO. YTH23V48 (96048001000), PRODUCT NO. 960 48 00-10

SCHEMATIC

SCH12

A

AMMETER (OPTIONAL)

WHITE

S

B M

	BATTERY	SOLENOID
		SOLENOID	STARTER
			STARTER
	RED		M
RED	FUSE		M
RED
		BLACK
		BLACK
	PTO SWITCH		ELECTRIC CLUTCH
	PTO SWITCH	WHITE	BLACK
	(DISENGAGED)
BLACK	H	WHITE
BLACK
	C

G

A1

GRAY

C F H

B E G

A D

PTO SWITCH

(MATING SIDE)

NOTES

L A2

BLACK

ORANGE

RED	A	D RED	CLUTCH/BRAKE
	A	D RED	CLUTCH/BRAKE
			(PEDAL UP)
	B	E
		BLACK		REVERSE SWITCH
		BLACK		(NOT IN REVERSE)
				(NOT IN REVERSE)
	BLACK
	BLACK
		2	BLACK
	BLACK	3		SEAT SWITCH
		3	BLACK	(NOT OCCUPIED)
	BLACK	1	BLACK
		1
		6	GRAY
		JUNCTION
		CONNECTOR
	/WHITE			SHORTING
	BLACK			SHORTING
		CHASSIS		CONNECTOR
		CHASSIS
		HARNESS
		IGNITION		SPARK
		UNIT		PLUGS GAP
			(2 PLUGS ON
		(OPTIONAL)	TWIN CYL. ENGINES)
		(OPTIONAL)
	BLUE	HOUR		BLACK
		METER
	FUEL	BLUE		12V	BLACK
	LINE			12V
	LINE
				POWER OUTLET
BLUE				(OPTIONAL)
		CHARGING SYSTEM OUTPUT
	FUEL SHUT-OFF	9 - 1 6 AMP DC @ 3600 RPM
	SOLENOID
	(IF EQUIPPED)	REGULATOR		STATOR
	RED	REGULATOR
	RED
			28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
		BROWN			BLACK
	LIGHT
	SWITCH
			HEADLIGHTS

				3	6	6	3
	IGNITION SWITCH
				2	5	5	2
	POSITION	CIRCUIT	“MAKE”
						4	1
	OFF	M+G+A1		1	4

	RUN/OVERRIDE	B+A1
	RUN	B+A1	L+A2	CHASSIS HARNESS		DASH HARNESS
	START	B + S + A1		CONNECTOR		CONNECTOR
				(MATING SIDE)

WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

NON-REMOVABLE CONNECTIONS

REMOVABLE CONNECTIONS

29

Image 29

Husqvarna YTH23V48 owner manual Schematic, SCH12

Contents

YTH23V48 II. Slope Operation Safe Operation Practices for Ride-On MowersGeneral Operation General Service ServiceIII. Children IV. Towing Table of Contents Toremovetractorfromcarton Tools Required for AssemblyBefore Removing Tractor from Skid Unpack Carton Check Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake System Operation Know Your Tractor To SET Parking Brake See Fig HOW to USE Your TractorStopping See Fig To USE Throttle Control D See Fig To Stop Mower Blades To Operate Mower Using the Reverse Operation System Service REMINDER/HOUR MeterReverse Operation System ROS To Operate on Hills Check Engine OIL Level Before Starting the EngineADD Gasoline To Start Engine See Fig Purge Transmission Mowing Tips Lubrication Chart MaintenanceGeneral Recommendations Schedule Tractor BatteryBlade Care Blade Removal See Fig Engine Muffler CleaningIN-LINE Fuel Filter See Fig Deck Washout Port See Fig To Remove Mower See Fig To Install Mower See Figs Turn Steering Wheel Left and Position Mower See Fig ANTI-SWAY BAR S Attach Mower Side Suspension Arms a to Chassis See Fig To Replace Mower Blade Drive Belt See Fig Mower Drive Belt InstallationTo Check Brake To Level Mower Belt Removal Belt InstallationTo Replace Motion Drive Belt See Fig To Remove Wheel See Fig To Start Engine with a Weak Battery See FigFront Wheel TOE-IN/CAMBER To Attach Jumper Cables Transmission Fuel System OtherEngine OIL Cylinders Problem Cause Correction Troubleshooting Engine continues KEY Part NO. NO. Description DecalsWheels and Tires SCH12 Schematic Electrical KEY Part Description Chassis Chassis 196 Drive Bolt Rdhd Sqnk 3/8-16 x 2-3/4 Gr Engine Spark Arrester KIT Engine Power Rating Information Steering Assembly Seat Assembly Mower Deck KEY Part NO. NO. Description Mower Lift Limitations and Exclusions HOW to Obtain Service Consumer Wheeled Warranty Chart Front Mounted Deck Riders Engine Transmission Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation 10.27.10 JA