Service Access
For partially or fully sunken installations, allow for ac- cess to service connections. It is the installer's respon- sibility to provide sufficient service access. See Ser- vice Access illustration. Provide adequate ventilation (minimum 30 square inch opening) for cooling the mo- tor and to supply sufficient air for the jets.
SERVICE ACCESS
BLOWER
MOTOR/PUMP
ACCESS | ACCESS |
CONTROL BOX
Electrical Connections
Two separate circuits are required for this unit:
Bath
Install a 115 VAC 30 AMP dedicated circuit protected by a Ground Fault Circuit Interrupter (GFCI). The unit must be hard wired (permanent) from this circuit to the con- trol box. Remove cover of control box and hard wire from GFCI circuit to terminal block.
DANGER: RISK OF ELECTRIC SHOCK. Connect only to a circuit protected by a Ground Fault Circuit
Interrupter.
Rapid Heat
Install a 120 VAC 15 AMP dedicated circuit with GFCI protection. The unit must be hard wired (permanent) from this circuit to the junction box for the heater (see below). For operation, refer to the RapidHeat instruc- tions.
DANGER: RISK OF ELECTRIC SHOCK. Connect only to a circuit protected by a Ground Fault Circuit Interrupter.
We recommend that a qualified electrician perform this work.
CAUTION: Operating the motor/pump without enough water in the bath can cause leaking and per- manent damage to the pump. Before power is ap- plied to the installation, make sure the switch is in the OFF position to avoid pump damage.
Bonding
Connect a #8 guage (10mm2) minimum solid copper bond wire from the house electrical pannel or an ap- proved local ground to all metal components (i.e. junc- tion box etc.). An approved ground may be an 8 foot long ground rod (3 meter long earth rod), a plate electrode or other acceptable bond location. Check your local build- ing code for requirements.
ELECTRICAL CONNECTIONS
| CONTROL BOX | |
| RAPIDHEAT | JUNCTION BOX |
BLACK | WIRE NUTS |
|
TO |
| FROM |
RAPIDHEAT |
| POWER |
|
| SUPPLY |
WHITE |
| GROUND |
| (GREEN) | |
|
| |
ELECTRICAL CONNECTION RAPIDHEAT
JUNCTION BOX
SEPERATE GFCI PROTECTED CIRCUIT (TO BATH CONTROL BOX)
SEPERATE GFCI
PROTECTED CIRCUIT
(FOR RAPIDHEAT)
RAPIDHEAT
7
