Land Pride RTR15, RTR1550, RTR1558 Lubrication

23

7/22/08 RTR10 & RTR15 Series Rotary Tillers 311-431M

Land Pride

Section 4: Maintenance and Lubrication

Table of Contents

20

Hrs

Multi-purpose

spray lube Multi-purpose

grease lube Multi-purpose

oil lube Intervals in hours at which

lubrication is required.

Lubrication

Legend

Lubrication

Driveline U-Joint

Coat driveline u-joint with grease every8 hours of

operation

Typeof grease = Multi-Purpose

Quantity = Coat Generously

Driveline Shaft

Disconnect driveline shaft from the tractor and slide apart.

Clean and coat the inner tube of the driveline shaft with a

light film of grease and then reassemble.

Typeof grease = Multi-Purpose

Quantity = Coat Generously

Chaincase

Type= Recommended: Shell Alvania EP00 Oil

Alternate: SAE 90 wt. oil

Quantity = As required

With tiller on levelground, check oil level in chaincase

byremoving lower plug. Oil should reach the plug hole.

Fill if necessary with Shell Alvania EP OO oil and

retighten plug. Tiller should be levelwhen checking.

As

Required

8

Hrs

20

Hrs

14191

14190

22245

Contents

Main ! Rotary Tillers Table of Contents Important Safety Information . . . . . . . . . . .1 Introduction . . . . . . . . . . . . . . . . . . . . . . . .8 Section 1: Assembly and Set-Up . . . . . . . .9 Section 2: Operating . . . . . . . . . . . . . . . .14 Safety at All Times ! ! Be Aware of Signal Words ! Transport Machinery Safely Use Safety Lights and Devices Practice Safe Maintenance Keep Riders Off Machinery Prepare for Emergencies Wear Protective Equipment Avoid High Pressure Fluids Hazard Safety Labels 818-130C Page 818-858C 818-552C ROTATING DRIVELINE KEEP AWAY! Page Introduction Table of Contents Serial Number Plate Further Assistance Land Pride Application Using This Manual Terminology Definitions Owner Assistance Hitch Assembly Leg Stand Assembly Front Deflector Assembly Rear Deflector Assembly Tractor Hook-Up Section 1: Assembly and Set-Up Table of Contents Driveline Installation Checking Driveline Minimum Length Checking Driveline Maximum Length Section 2: Operating Table of Contents General Notes for Field Operations Operating Check List Transporting Section 2: Operating Table of Contents Parking Operating Instructions RTR10 Tiller Hitch Offset Drive Chain Rear Deflector Skid Shoe Adjustment Maintenance Tine Replacement Driveline Protection Clutches With 4 Adjusting Nuts Clutch Run-In 2-Plate Disassembly 2-Plate Assembly Clutches With 8 Hex Socket Bolts Clutch Run-In Clutch Disassembly & Assembly Shearbolt Protection Shear Bolt and Lock Nut Part Numbers Storage Lubrication Legend Lubrication Driveline U-Joint Driveline Shaft Chaincase Bearing On Right End Of Rotor Shaft Gearbox Section 5: Specications & Capacities 25 RTR10 Series Rotary Tiller Model RTR1042 RTR1050 RTR1058 RTR15 Series Rotary Tiller Section 6: Features & Benets Table of Contents RTR10 Series Rotary Tiller Features Benefits 27 Section 6: Features & Benets Table of Contents RTR15 Series Rotary Tiller Features Benefits 28 Section 7: Troubleshooting Table of Contents Problem Cause Solution Machine makes intermittent clicking noise Driveline vibrates Gearbox noise is noticeable and constant Torque Values Chart in-tpi 1 Nm ft-lb 3N m ft-lb N m ft-lb mmx pitch N m ft-lb N m ft-lb N m ft-lb Page Section 8: Appendix Table of Contents Warranty